2Twenty2
FAILTuesday, December 3, 2019 at 4:27 PM
Violations Cited
590.002/2-301.14-P
When to Wash (P)
observed employees walking around kitchen touching walls with gloves not remove gloves and wash hands before food prep
Why This Matters
ILLNESS TRANSMISSION: 70% of foodborne outbreaks traced to poor handwashing. Unwashed hands after restroom carry 10 billion bacteria including E. coli. One contaminated hand can spread bacteria to 7 surfaces in 10 seconds. Causes 48 million illnesses annually.
Code Requirements
Wash hands for 20 seconds minimum with soap and 100°F water: After restroom ALWAYS, Before food prep, After touching face/hair/clothing, Between raw and ready-to-eat foods, After handling garbage, Every 30 minutes during continuous prep, After any contamination risk.
590.003/3-302.11-P
Packaged and Unpackaged Food-Separation Packaging and Segregation (P)
raw chicken stored above ready to eat foods
Why This Matters
DIRECT CONTAMINATION PATH: Raw chicken contains Salmonella (23% of samples) and Campylobacter (71% of samples). One drop of raw chicken juice can contaminate entire shelf below. Results in 1-3 million US illnesses annually.
Code Requirements
REORGANIZE IMMEDIATELY - Top to bottom: Ready-to-eat foods, Fish/Seafood (145°F), Whole meat/pork (145°F), Ground meat (155°F), Poultry (165°F) on bottom. Use separate coolers if needed. Cover all foods. Train all staff on proper order.
590.003/3-501.14-P
Cooling (P)
provide proper cooling methods for boiled chicken
Why This Matters
TOXIN FORMATION: Clostridium perfringens spores survive cooking and germinate during slow cooling. Produce toxin that causes violent illness. Responsible for 1 million illnesses annually. Large batches can take 24+ hours to cool unsafely.
Code Requirements
Cool rapidly using: Shallow pans (2 inches max), Ice baths with stirring, Blast chiller, Cut large items into portions, Add ice as ingredient. NEVER cool at room temp. NEVER stack hot containers. Monitor with thermometer. Document cooling times.
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
boiled chicken 82 degrees in reach in
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.002(D)/2-103.11-PF
(A)-(P) Person-In-Charge-Duties (Pf)
provide PIC during all hours of operation
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(D). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.002/2-501.11-PF
Clean-up of Vomiting and Diarrheal Events (Pf)
provide vomit clean up kit
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.003/3-501.17-PF
Ready-To-Eat Time/Temperature Control for Safety Food Date Marking (Pf)
properly date mark all ready to eat foods held over 24 hours
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper temperature control procedures. Train all staff. Document corrective actions taken.
590.004/4-302.12-PF
Food Temperature Measuring Devices (Pf)
properly calibrate cooks thermometer
Why This Matters
TEMPERATURE ABUSE: Without thermometers, 73% of foods are held at unsafe temperatures. Bacteria double every 20 minutes between 41-135°F. Undercooked ground beef (not reaching 155°F) causes E. coli outbreaks affecting hundreds.
Code Requirements
Provide calibrated probe thermometers immediately: One per cook station minimum, Range -40°F to 200°F, Accurate to ±2°F, Calibrate daily in ice water (32°F). Check temps every 2 hours for holding, always for cooking.
590.006/6-301.12-PF
Hand Drying Provision (Pf)
dishroom handsink and bar handsinks/provide paper towels in dispenser
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
590.008/8-103.12-PF
Conformance with Approved Procedures (Pf)
provide full HACCP plan with lab test employee sign off sheets confirmation letters and recipes provide calibrated ph meter/sushi chef testing rice ph with quat test kit provide expiration dates on buffer solutions
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.008. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.002/2-402.11-C
Effectiveness-Hair Restraints (C)
provide proper hair restraints
Why This Matters
CONTAMINATION RISK: Average person sheds 50-100 hairs daily. Each hair can carry up to 1 million bacteria. Staphylococcus aureus from hair causes rapid food poisoning (1-6 hours) with severe nausea, vomiting, and cramps. Cannot be killed by reheating once toxin forms.
Code Requirements
All staff handling food MUST wear: hairnets, caps, or effective hair restraints covering all hair; beard nets for facial hair over 1/4 inch; no loose hair touching shoulders. Provide hair restraints for all staff immediately.
590.003/3-305.14-C
Food Preparation (C)
provide cover to all employee drinks
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-204.112-C
Temperature Measuring Devices-Functionality (C)
provide internal thermometer to reach in unts
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper temperature control procedures. Train all staff. Document corrective actions taken.
590.004/4-501.12-C
Cutting Surfaces (C)
resurface worn white cutting boards
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.005/5-205.15-C
System Maintained in Good Repair (C)
repair mixing valve to timed handsink in mens restroom repair stall in ladies restroom
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-301.14-C
Handwashing Signage (C)
bar handsinks/provide employee must wash hands signage
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
590.006/6-501.11-C
Repairing-Premises Structures Attachments and Fixtures-Methods (C)
provide ice scoop to ice machine 3 door sushi/remove cardboard from shelving hot line/replace burnt out lights clean interior of hot line hood
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-501.114-C
Maintaining Premises Unnecessary Items and Litter (C)
clean/organize dry storage room/remove opened products /no covered ceiling in dry storage room/label piping
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper food safety procedures. Train all staff. Document corrective actions taken.