Achilitos Taqueria
PASSTuesday, August 6, 2024 at 4:55 PM
Violations Cited
590.003/3-403.11-P
Reheating for Hot Holding (P)
Staff observed reheating multiple proteins below 165F. All proteins final reheating temperaure of 165F and up was veryfied before placing in the hot holding. PIC to retrain staff on reheating.
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Maintain all hot TCS foods at 135°F or above; Cannot use hot holding equipment to reheat
590.003/3-501.14-P
Cooling (P)
Employee observed prepping guacamole final temperature 48F and ready to sell before cooling. CFPM to retrain staff on cooling process. Guacamolec was removed and place in the walking cooler. Final temperaure: Guacamole 38F.
Why This Matters
TOXIN FORMATION: Clostridium perfringens spores survive cooking and germinate during slow cooling. Produce toxin that causes violent illness. Responsible for 1 million illnesses annually. Large batches can take 24+ hours to cool unsafely.
Code Requirements
Cool rapidly using: Shallow pans (2 inches max), Ice baths with stirring, Blast chiller, Cut large items into portions, Add ice as ingredient. NEVER cool at room temp. NEVER stack hot containers. Monitor with thermometer. Document cooling times.
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Guacamole temp at 48F pico de galo 45F mango salsa 51F diced tomato 45F sweet corn 46F. All products were pepped 30 minutes before. All products were palced in the walking cooler until temperature of 41F below was reached. Retrain staff to monitor cold holding temperature. Unit temp at 37F thermometer located inside of unit. Corrected on site
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.003/3-501.16-P1
(A)(1) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Hot holding :Chicken 118F Pork 112-128F beef 106F all products were discard by chef and PIC. PIC to review hot holding and train staff.
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.002(D)/2-103.11-PF
(A)-(P) Person-In-Charge-Duties (Pf)
Designate a PIC who's knowlegeable and present at all ours of operation. Person in charge must be present demonstrates knowledge and performs duties PIC was unable to demonstrate cooling process illness policy cold holding and reheating. Educational material will be provided for PIC to retrain and train staff.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(D). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.005/5-103.11-PF
Capacity-Quantity and Availability (Pf)
Hot water throughout the establishement observed fluctuating between 60F-115F. Repair.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-301.11-PF
Handwashing Cleanser Availability (Pf)
No hand soap available at the warewashing and kitchen main hand sink. Provide and maintain. (COS)
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
590.002/2-402.11-C
Effectiveness-Hair Restraints (C)
Staff prepping guacamole observed without hair restraint. Provide (COS)
Why This Matters
CONTAMINATION RISK: Average person sheds 50-100 hairs daily. Each hair can carry up to 1 million bacteria. Staphylococcus aureus from hair causes rapid food poisoning (1-6 hours) with severe nausea, vomiting, and cramps. Cannot be killed by reheating once toxin forms.
Code Requirements
All staff handling food MUST wear: hairnets, caps, or effective hair restraints covering all hair; beard nets for facial hair over 1/4 inch; no loose hair touching shoulders. Provide hair restraints for all staff immediately.
590.003/3-304.12-C
In-Use Utensils Between-Use Storage (C)
In use knife and utensils observed stored in stagnant water. Discontinue.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.003/3-307.11-C
Miscellaneous Sources of Contamination (C)
Observed staff washing avocados in the 3 bay sink . Discontiue start using available prep sink after wash rinse and sanitize.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.005/5-501.17-C
Toilet Room Receptacle Covered (C)
Bathroom trash can observed without cover. Provide
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-301.14-C
Handwashing Signage (C)
No employee must wash hand sign observed at the warewashing and kitchen main hand sink. Provide
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.