AFC Zenshi @ Shaws 4587
PASSFriday, October 23, 2020 at 2:40 PM
Violations Cited
590.002/2-301.14-P
When to Wash (P)
Employee observed handling soiled equipment then prepping food without washing his hands.
Why This Matters
ILLNESS TRANSMISSION: 70% of foodborne outbreaks traced to poor handwashing. Unwashed hands after restroom carry 10 billion bacteria including E. coli. One contaminated hand can spread bacteria to 7 surfaces in 10 seconds. Causes 48 million illnesses annually.
Code Requirements
Wash hands for 20 seconds minimum with soap and 100°F water: After restroom ALWAYS, Before food prep, After touching face/hair/clothing, Between raw and ready-to-eat foods, After handling garbage, Every 30 minutes during continuous prep, After any contamination risk.
590.003/3-501.14-P
Cooling (P)
Cooked brown rice cooling in deep plastic container from 140F to 136F in 15 minutes. Cool properly to ensure time / temperature requirements are met. CFPM removed and placed in freezer to begin proper cooling.
Why This Matters
TOXIN FORMATION: Clostridium perfringens spores survive cooking and germinate during slow cooling. Produce toxin that causes violent illness. Responsible for 1 million illnesses annually. Large batches can take 24+ hours to cool unsafely.
Code Requirements
Cool rapidly using: Shallow pans (2 inches max), Ice baths with stirring, Blast chiller, Cut large items into portions, Add ice as ingredient. NEVER cool at room temp. NEVER stack hot containers. Monitor with thermometer. Document cooling times.
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Packaged sushi stored in retail case 46F. Prepared and placed in self service case. Chill properly to 41F or below before placing into service case.
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.004/4-602.11-P
Equipment Food-Contact Surfaces and Utensils-Frequency (P)
Employee observed wiping a knife with a plastic bag and rinsing the plastic topping bags at the prep sink. Food contact equpment must be properly washed rinsed and sanitized between use. Repeat violation.
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.002(D)/2-103.11-PF
(A)-(P) Person-In-Charge-Duties (Pf)
CFPM Angtengen Sherpa is not monitoring Lakpa Sherpa as evident by failure of Lakpa to properly wash hands and clean / sanitize equipment properly between use. These are repeat violations noted on other inspections
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(D). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-501.13-C
Thawing (C)
Fish thawed in ROP packaging. Discontinue.
Why This Matters
SURFACE CONTAMINATION: Room temperature thawing allows surface to reach 70°F+ while interior frozen. Bacteria multiply 7-fold every hour. Creates perfect conditions for Salmonella, Campylobacter growth. Major factor in poultry-related illnesses.
Code Requirements
Approved thawing methods ONLY: Under refrigeration (best), Under cold running water (70°F) in sink, In microwave if cooking immediately, As part of cooking process. NEVER at room temperature. Plan ahead for slow thawing.
590.004/4-201.11-C
Equipment and Utensils-Durability and Strength (C)
Non comercial grade colored collander. Replace.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.005/5-205.15-C
System Maintained in Good Repair (C)
Sushi Area: Hand sink leaking from drain pipe. Seafood 3 bay sink - When rinse bay drains it backs up into sanitizer bay. Repair.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper food safety procedures. Train all staff. Document corrective actions taken.