Bennetts Sandwich Shop
PASSFriday, July 13, 2018 at 3:48 PM
Violations Cited
03-3-501.16(A)
Cold Holding
Multiple products placed at cold hold service line at above 41F. Unit not turned on at time of inspection. Cut tomatoes 46F Sliced meats 48F Turkey 49F. Unit turned on products removed and placed in freezer to lower temperature to 41F or below. Ensure unit is turned on before placing products in it for service
Why This Matters
THE DANGER ZONE KILLS: Between 41°F-135°F bacteria double every 20 minutes. At 70°F, 10 bacteria become 10,000 in 2 hours, 10 million in 4 hours. Staphylococcus aureus produces heat-stable toxins that cooking cannot destroy. Clostridium perfringens causes 1 million illnesses yearly from temperature abuse. Listeria grows even under refrigeration, killing 20% of victims including pregnant women and newborns.
Code Requirements
ALL TCS foods MUST be held at 41°F or below at ALL times. This includes: All meat, poultry, seafood; Dairy products; Cut melons, tomatoes, leafy greens; Cooked rice, pasta, potatoes; Tofu, soy products; Sprouts; Garlic in oil. Check temperatures every 2 hours (4 hours maximum). If above 41°F for less than 2 hours, rapidly cool. If above 41°F for 2-4 hours, use immediately. If above 41°F for over 4 hours, DISCARD.
Corrective Actions
IMMEDIATE: Check ALL refrigerated foods NOW; Discard any food above 41°F for >4 hours; Rapidly cool foods 41-70°F if <4 hours; Repair/adjust all refrigeration immediately; Reduce inventory to prevent overstocking; Install thermometers in warmest part of all coolers; Implement 2-hour temperature checks; Create power outage procedure
M-2-103.11
PIC Performing Duties
PIC must ensure proper maintainance of establishment including cleaning of all areas and scheduling of hood cleaning. PIC must properly monitor equipment and temperature holding procedures for PHFs
Why This Matters
EXTREME RISK: Without active management, ALL five CDC risk factors go unchecked. Studies show restaurants without certified managers have 2.5 times more critical violations. Lack of supervision leads to: temperature abuse (bacteria double every 20 minutes), cross-contamination spreading pathogens, sick employees working with food, improper cooking allowing pathogen survival. This single violation enables conditions for major outbreaks.
Code Requirements
PIC MUST: Be present during ALL operating hours; Hold valid food safety certification; Actively monitor employee health and hygiene; Ensure proper cooking, cooling, and holding temperatures; Verify foods from approved sources; Monitor handwashing compliance; Ensure equipment properly sanitized; Take immediate corrective actions for violations; Demonstrate knowledge to health inspector; Train and supervise all food employees.
Corrective Actions
IMMEDIATE: Designate qualified PIC immediately; If no certified manager available, cease operations; Implement active managerial control system; Create monitoring logs for all CDC risk factors; Retrain management on responsibilities; Post PIC duties checklist
35-6-501.111/.115
Insects Rodents Animals
Evidence of dried rodent droppings in lower level. Numerous small black flies noted in both upper and lower areas- Provide updated detailed pest control report to Health Department Evidence of rodent activity on the exterior of building (Holes) Spaces noted at bottoms of doors at both exit of establishment and exit to building- Repair
Why This Matters
DISEASE VECTORS: Mice produce 50-75 droppings daily containing Salmonella, Hantavirus. Cockroaches carry 33 types of bacteria, 6 parasitic worms. Flies regurgitate and defecate on food, spreading E. coli, Shigella. One mouse can contaminate 10 times more food than it eats. Pest allergens trigger asthma in 26% of inner-city children.
Code Requirements
Facility must be pest-free: No live or dead pests; No droppings or urine; No gnaw marks or rub marks; No nesting materials; Effective pest control program; Monthly professional service recommended; All openings sealed; Remove harborage conditions.
Corrective Actions
Call pest control service immediately; Discard ALL contaminated food; Clean and sanitize all affected areas; Seal all openings larger than 1/4 inch; Install door sweeps; Eliminate standing water; Remove clutter; Increase cleaning frequency
17-4-302.14
Test Kit Provided
No test kit for quats sanitizer- Provide
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
21-3-304.14
Wiping Cloths Clean Sanitize
Sponges used at 3 bay- Discontinue
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
34-5-501.111/.115
Outside Storage Improperly Maintained
Exterior of building where grease drums are stored with excessive amounts of greas soils and debris on ground. Area located directly outside exit of building. Per PIC building responsible to clean area. Shared space for all establishments in building. Clean area with proper frequency
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food storage procedures. Train all staff. Document corrective actions taken.
36-6-501.11-.12
Improper Maintenance of Floors
Floors under and around equipment in both upper service area and in lower prep with heavy soils and debris- Clean with proper frequency
Why This Matters
CONTAMINATION RESERVOIR: Damaged floors harbor bacteria in cracks. Standing water breeds Listeria, Pseudomonas. Broken tiles create pest harborage. Floor contamination spreads via shoes, equipment wheels, and dropped items. CDC found floor drains positive for Listeria in 40% of retail delis.
Code Requirements
Floors must be: Smooth and non-porous in food areas; Properly sloped to drains (1/8 to 1/4 inch per foot); Coving at wall junctures sealed; No cracks, holes, or missing tiles; Grout intact and sealed; Cleaned daily or more frequently; Dry except when cleaning.
Corrective Actions
Schedule floor repairs within 30 days; Seal all cracks immediately with approved sealant; Improve drainage to eliminate standing water; Increase cleaning frequency; Replace missing tiles; Re-grout as needed; Remove any carpeting from food areas
37-6-501.11-.12
Improper Maintenance of Walls/Ceilings
Hoods with heavy dripping grease- Clean with proper frequency *Hood sticker expired September 2017- Refer to BFD
Why This Matters
OVERHEAD CONTAMINATION: Peeling paint and debris fall into food. Condensation on ceilings drips bacteria onto prep surfaces. Studies found ceiling tiles harbor Bacillus cereus spores. Restaurant ceiling collapse contaminated food service for 200 guests.
Code Requirements
Walls/ceilings must be: Smooth and washable in food areas; Light-colored for easy soil detection; Free of holes, cracks, peeling paint; Sealed at all joints and attachments; Clean and free of grease, dust, cobwebs; Non-absorbent in areas subject to moisture.
Corrective Actions
Repair all holes within 14 days; Repaint with washable paint; Replace damaged ceiling tiles; Seal all penetrations; Clean walls and ceilings monthly; Fix any leaks immediately; Install FRP panels in splash zones
38-6-202.11
Fixture's not properly shielded
Multiple lights in lower level with no shields- Provide
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.