BERTUCCI'S
FAILFriday, June 2, 2023 at 4:05 PM
Violations Cited
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Multiple items on prep line between 45F and 49F. Please close lid when not in use to hold temperature at 41F or below. Unit was at 36F
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.004/4-501.114-P
Manual and Mechanical Warewashing Equipment Chemical Sanitization-Temperature pH Concentration and Hardness (P)
Low temperature dishwasher at bar did not have sanitizer hooked up. PIC will use the kitchen until repaired.
Why This Matters
INEFFECTIVE SANITIZATION: Below 50ppm chlorine or 200ppm quat, bacteria survive on 'clean' dishes. Above 200ppm chlorine leaves toxic residue causing chemical burns, nausea. 70% of restaurant outbreaks linked to improper sanitization.
Code Requirements
Maintain sanitizer at: Chlorine 50-100ppm, Quaternary Ammonium 200-400ppm, Iodine 12.5-25ppm. Test every 2 hours with test strips. Change solution when cloudy/dirty. Train all staff on mixing procedures.
590.003/3-302.12-C
Food Storage Containers Identified with Common Name of Food (C)
Large and small bulk food containers will need to have labels.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.004/4-202.16-C
Nonfood-Contact Surfaces (C)
Clean shelves on cooking and prep line. Clean wire shelves in walk in. PIC will need to replace the moldy caulking in warewashing room. Both visibly soiled.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-202.18-C
Ventilation Hood Systems Filters (C)
Hood sticker above oven used for rolls has an expired sticker and visibly hood parts will need to be cleaned. Filters and holder on hood on cooking line will need to be cleaned.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-201.11-C
Floors Walls and Ceilings-Cleanability (C)
Clean the floor under and behine dishwasher and grease trap. Walls in warewashing will need to be cleaned.
Why This Matters
Poor facility maintenance can harbor pests and prevent proper cleaning
Code Requirements
Smooth, non-porous surfaces; Properly sloped to drains; No gaps or cracks; Maintained clean
590.006/6-201.17-C
Walls and Ceilings Attachments (C)
As discussed please clean the condencer and the fan covers in the walk ins.
Why This Matters
Poor facility maintenance can harbor pests and prevent proper cleaning
Code Requirements
Smooth, washable surfaces; No holes or damage; Light-colored in food areas; Clean condition