D Coal Pot
FAILThursday, April 25, 2024 at 6:24 PM
Violations Cited
590.003/3-302.11-P
Packaged and Unpackaged Food-Separation Packaging and Segregation (P)
Raw food stored on the top shelf of the refrigeration unit in the basement. Remove and store on bottom shelf.
Why This Matters
DIRECT CONTAMINATION PATH: Raw chicken contains Salmonella (23% of samples) and Campylobacter (71% of samples). One drop of raw chicken juice can contaminate entire shelf below. Results in 1-3 million US illnesses annually.
Code Requirements
REORGANIZE IMMEDIATELY - Top to bottom: Ready-to-eat foods, Fish/Seafood (145°F), Whole meat/pork (145°F), Ground meat (155°F), Poultry (165°F) on bottom. Use separate coolers if needed. Cover all foods. Train all staff on proper order.
590.004/4-501.114-P
Manual and Mechanical Warewashing Equipment Chemical Sanitization-Temperature pH Concentration and Hardness (P)
Sanitizer buckets have soap and water inside. Ensure that you are using commerical grade sanitizer Quateranary or Chlorine sanitizer.
Why This Matters
INEFFECTIVE SANITIZATION: Below 50ppm chlorine or 200ppm quat, bacteria survive on 'clean' dishes. Above 200ppm chlorine leaves toxic residue causing chemical burns, nausea. 70% of restaurant outbreaks linked to improper sanitization.
Code Requirements
Maintain sanitizer at: Chlorine 50-100ppm, Quaternary Ammonium 200-400ppm, Iodine 12.5-25ppm. Test every 2 hours with test strips. Change solution when cloudy/dirty. Train all staff on mixing procedures.
590.005/5-203.14-P
Backflow Prevention Device When Required (P)
Prep sink is direct to waist. Utilize a colander until properly plumbed. Contact a licensed plumber.
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.002/2-501.11-PF
Clean-up of Vomiting and Diarrheal Events (Pf)
No vomit & diarrhea kit onsite. Provide vomit & diarrhea kit. Emailed PIC list of supplies and instructions.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.004/4-302.12-PF
Food Temperature Measuring Devices (Pf)
No food thermometer on site. Provide food thermometer.
Why This Matters
TEMPERATURE ABUSE: Without thermometers, 73% of foods are held at unsafe temperatures. Bacteria double every 20 minutes between 41-135°F. Undercooked ground beef (not reaching 155°F) causes E. coli outbreaks affecting hundreds.
Code Requirements
Provide calibrated probe thermometers immediately: One per cook station minimum, Range -40°F to 200°F, Accurate to ±2°F, Calibrate daily in ice water (32°F). Check temps every 2 hours for holding, always for cooking.
590.004/4-302.14-PF
Sanitizing Solutions Testing Devices (Pf)
No test kit available. Provide a test kit.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.004/4-303.11-PF
Cleaning Agents and Sanitizers Availability (Pf)
No sanitizer available for the 3 bay sink. PIC went and purchased a bottle. Corrected on site.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.004/4-501.19-PF
Manual Warewashing Equipment Wash Solution Temperature (Pf)
3 bay sink at 78F. Maintain at or above 110F to remove soil and grease.
Why This Matters
Improper equipment maintenance can harbor bacteria and contaminate food
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper temperature control procedures. Train all staff. Document corrective actions taken.
590.005/5-202.12-PF
Handwashing Sinks Installation (Pf)
Hand sink temperature 78F. Adjust temperature at mimimum to 100F.
Why This Matters
WITHOUT HOT WATER: Bacteria removal drops by 75%. Studies show proper handwashing with hot water and soap removes 99.9% of bacteria, while cold water only removes 25%. This dramatically increases risk of spreading E. coli, Salmonella, and Norovirus - responsible for 89% of foodborne illness outbreaks.
Code Requirements
Immediate action required: Provide hot water (100-120°F) at ALL handwashing sinks. Install water heater if needed. Temporary solution: heat water for handwashing until repairs complete. Staff must wash hands every 30 minutes, after touching face/hair, handling raw foods, using restroom.
590.006/6-301.11-PF
Handwashing Cleanser Availability (Pf)
No hand soap at the hand sink in the kitchen area. Provide hand soap.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
590.006/6-301.12-PF
Hand Drying Provision (Pf)
No paper towels or means to properly dry hands. Provide proper means to dry hands.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
590.004/4-602.13-C
Nonfood Contact Surfaces (C)
Observed grease on the side of the hood. Clean to remove grease. Observed heavy soil on the interior and exterior of the all refrigeration units. Clean to remove soil. Observed heavy soil on the fan. Clean to remove soil. Observed heavy soil on the fan in the wash area. Clean to remove grease or discontinue using.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-603.16-C
Rinsing Procedures (C)
Observed soiled pots and pan inside the rinse bin and the sanitizer bin. Follow proper procedures to wash rinse and sanitize.
Why This Matters
RECONTAMINATION: Towel drying removes sanitizer film that continues killing bacteria. Introduces new bacteria from towel - even 'clean' towels have 100,000+ bacteria. Spreads contamination across all dried items.
Code Requirements
ALWAYS air dry after sanitizing. No towel drying ever. Adequate drain boards/racks required. Allow complete drying before stacking. If must handle wet items, use single-use paper towels. Towels for drying hands only.
590.004/4-903.11-C
(A) and (C) Equipment Utensils Linens and Single-Service and Single-Use Articles-Storing (C)
Observed pots and pans not inverted. Properly store pots and pans .
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.006/6-201.11-C
Floors Walls and Ceilings-Cleanability (C)
Observed heavy soil on the floors and walls. Clean to remove all soil and grease.
Why This Matters
Poor facility maintenance can harbor pests and prevent proper cleaning
Code Requirements
Smooth, non-porous surfaces; Properly sloped to drains; No gaps or cracks; Maintained clean
590.006/6-501.11-C
Repairing-Premises Structures Attachments and Fixtures-Methods (C)
Observed grout lines worn out. Repair grout to ensure the floor is easily cleanable.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-501.114-C
Maintaining Premises Unnecessary Items and Litter (C)
Observed unnecessary items being stored in the basement upstairs and outside. Remove all unused/ broken items.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper food safety procedures. Train all staff. Document corrective actions taken.