D'ANGELO'S SANDWICH SHOP
FAILWednesday, August 10, 2016 at 3:40 PM
Violations Cited
03-3-501.16(A)
Cold Holding
Sandwich unit 55 F Tuna 49 F Turkey 52 F PIC took corrective action by calling refrigeration unit and removing food products from unit. Refrigeration units must maintain 41 F or below at all times
Why This Matters
THE DANGER ZONE KILLS: Between 41°F-135°F bacteria double every 20 minutes. At 70°F, 10 bacteria become 10,000 in 2 hours, 10 million in 4 hours. Staphylococcus aureus produces heat-stable toxins that cooking cannot destroy. Clostridium perfringens causes 1 million illnesses yearly from temperature abuse. Listeria grows even under refrigeration, killing 20% of victims including pregnant women and newborns.
Code Requirements
ALL TCS foods MUST be held at 41°F or below at ALL times. This includes: All meat, poultry, seafood; Dairy products; Cut melons, tomatoes, leafy greens; Cooked rice, pasta, potatoes; Tofu, soy products; Sprouts; Garlic in oil. Check temperatures every 2 hours (4 hours maximum). If above 41°F for less than 2 hours, rapidly cool. If above 41°F for 2-4 hours, use immediately. If above 41°F for over 4 hours, DISCARD.
Corrective Actions
IMMEDIATE: Check ALL refrigerated foods NOW; Discard any food above 41°F for >4 hours; Rapidly cool foods 41-70°F if <4 hours; Repair/adjust all refrigeration immediately; Reduce inventory to prevent overstocking; Install thermometers in warmest part of all coolers; Implement 2-hour temperature checks; Create power outage procedure
08-3-302.11/3-304.11
Separation Segregation Cross Contamination
Raw chicken stored next to food items cooked to a lower temperature on open top refrigeration unit (APW unit) Raw shaved steak stored next to food items cooked to a lower temperature on open top refrigeration unit (APW unit)
Why This Matters
Cross-contamination can spread dangerous pathogens throughout the facility
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
12-2-301.12-.15
Adequate Handwashing/Where/When/How
Observed food handlers multitasking wearing gloves - Educate employees on proper glove use Observed employees not washing hand before placing on gloves Some important tips to remember; • Gloves are task specific and should NEVER be worn continuously. They get contaminated just as bare hands do so change them out frequently. • Wash your hands properly in between these changes i.e. (a 20 second scrub with soap warm water and don’t forget to dry off with a clean paper towel). • Gloves are not a stand-alone protective barrier. As mentioned above they are not 100% effective but when combined with proper hand washing they significantly reduce the possibility of contaminating your customer’s food. • Gloves can still cross-contaminate. Don’t touch the ready-to-eat food if you have just handled a raw piece of meat or eggs. Throw away the gloves wash your hands and put on a new pair. • If you touch a dirty surface with your glove (hair nose clothing floor equipment or utensils) the glove is dirty and you need to change them after washing your hands. • Bacteria from your skin continue to grow while underneath the gloves and that is why it is important to wash between handling the new gloves. Don’t pre-contaminate your gloves. • Non-latex gloves are recommended in Massachusetts. Keep a box of gloves in a readily accessible area. Perhaps by the hand wash sink. Being careful not to contaminate them here either. • Gloves used for food contact should not be used for money trash cleaning of soiled surfaces
Why This Matters
Inadequate handwashing is a leading cause of foodborne illness transmission
Code Requirements
Immediate correction required. Follow health code section . Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
M-2-103.11
PIC Performing Duties
Person in charge must oversee day to day operations and take corrective action All employees must be properly trained in food safety and sanitization as it relates to their assigned duties Multiple risk factors noted on inspection report - Imporper Temperatures of equipment/potentially hazardous foods hand washing/glove use storage of raw animal poducts.
Why This Matters
EXTREME RISK: Without active management, ALL five CDC risk factors go unchecked. Studies show restaurants without certified managers have 2.5 times more critical violations. Lack of supervision leads to: temperature abuse (bacteria double every 20 minutes), cross-contamination spreading pathogens, sick employees working with food, improper cooking allowing pathogen survival. This single violation enables conditions for major outbreaks.
Code Requirements
PIC MUST: Be present during ALL operating hours; Hold valid food safety certification; Actively monitor employee health and hygiene; Ensure proper cooking, cooling, and holding temperatures; Verify foods from approved sources; Monitor handwashing compliance; Ensure equipment properly sanitized; Take immediate corrective actions for violations; Demonstrate knowledge to health inspector; Train and supervise all food employees.
Corrective Actions
IMMEDIATE: Designate qualified PIC immediately; If no certified manager available, cease operations; Implement active managerial control system; Create monitoring logs for all CDC risk factors; Retrain management on responsibilities; Post PIC duties checklist
10-3-304.12
Food Utensil Storage
Ice scoop stored in ice bucket - provide proper storage
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper equipment procedures. Train all staff. Document corrective actions taken.
15-4-202.16
Non-Food Contact Surfaces
No barrier between mop sink and 3 bay sink - Enclose mop sink
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
15-4-202.16
Non-Food Contact Surfaces
2 door refrigeration unit next to hand sink in prep area 48 F Refrigeration units must maintain 41 F or below at all times
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
24-4-903.11
Clean Equipment & Utensils Storage
Ice bucket not inverted
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
37-6-501.11-.12
Improper Maintenance of Walls/Ceilings
Built up soils on ceiling and attachment throughout
Why This Matters
OVERHEAD CONTAMINATION: Peeling paint and debris fall into food. Condensation on ceilings drips bacteria onto prep surfaces. Studies found ceiling tiles harbor Bacillus cereus spores. Restaurant ceiling collapse contaminated food service for 200 guests.
Code Requirements
Walls/ceilings must be: Smooth and washable in food areas; Light-colored for easy soil detection; Free of holes, cracks, peeling paint; Sealed at all joints and attachments; Clean and free of grease, dust, cobwebs; Non-absorbent in areas subject to moisture.
Corrective Actions
Repair all holes within 14 days; Repaint with washable paint; Replace damaged ceiling tiles; Seal all penetrations; Clean walls and ceilings monthly; Fix any leaks immediately; Install FRP panels in splash zones
37-6-501.11-.12
Improper Maintenance of Walls/Ceilings
Hood sticker does not indicate date of cleaning performed and follow up date. Deficencies not marked yes or no Hood filters not closed and tight fitting
Why This Matters
OVERHEAD CONTAMINATION: Peeling paint and debris fall into food. Condensation on ceilings drips bacteria onto prep surfaces. Studies found ceiling tiles harbor Bacillus cereus spores. Restaurant ceiling collapse contaminated food service for 200 guests.
Code Requirements
Walls/ceilings must be: Smooth and washable in food areas; Light-colored for easy soil detection; Free of holes, cracks, peeling paint; Sealed at all joints and attachments; Clean and free of grease, dust, cobwebs; Non-absorbent in areas subject to moisture.
Corrective Actions
Repair all holes within 14 days; Repaint with washable paint; Replace damaged ceiling tiles; Seal all penetrations; Clean walls and ceilings monthly; Fix any leaks immediately; Install FRP panels in splash zones