FOOD WALL CHINESE
FAILWednesday, April 11, 2018 at 6:58 PM
Violations Cited
03-401.11-.12
Cooking Temperatures
Partially cooked chicken tenders out at room temperature ( two dozen ) 90F undetermined amount of time in the danger zone. Discarded voluntary- fully cook products to proper temperature 165F ) and / or hot hold at 140F as discussed during inspection
Why This Matters
DEADLY CONSEQUENCES: Undercooked foods kill. Salmonella in undercooked chicken affects 1.35 million Americans yearly, killing 420. E. coli O157:H7 in undercooked ground beef causes kidney failure in children. Undercooked pork can transmit Trichinella parasites. Raw eggs may contain Salmonella Enteritidis. Just 10 E. coli bacteria can cause severe illness. Cooking is the ONLY step that kills pathogens in contaminated food.
Code Requirements
MINIMUM COOKING TEMPERATURES: Poultry (chicken, turkey, duck): 165°F for 15 seconds; Ground meats (beef, pork, lamb): 155°F for 15 seconds; Eggs for hot holding: 155°F for 15 seconds; Whole meats (beef, pork, lamb): 145°F for 15 seconds; Fish and seafood: 145°F for 15 seconds; Reheated foods: 165°F within 2 hours; Microwave cooking: 165°F and let stand 2 minutes. MUST verify with calibrated thermometer in thickest part.
Corrective Actions
IMMEDIATE: Continue cooking ALL undercooked items to proper temperature; Discard if cannot reheat properly; Calibrate all thermometers NOW; Post cooking temperature chart at all stations; Assign temperature checking to specific staff; Log all cooking temperatures; Retrain all cooks immediately
12-2-301.12-.15
Adequate Handwashing/Where/When/How
Prep cooks not washing hands during multi task jobs corrected during inspection
Why This Matters
Inadequate handwashing is a leading cause of foodborne illness transmission
Code Requirements
Immediate correction required. Follow health code section . Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
12-2-401.11-.12
Good Hygienic Practices
Prep cook smoking tobacco inside the restaurant not washing hands in between tasks
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
M-2-103.11
PIC Performing Duties
Not overseeing proper hand washing hygienic practices cookng temperatures. Address as discussed during inspection . literature provided
Why This Matters
EXTREME RISK: Without active management, ALL five CDC risk factors go unchecked. Studies show restaurants without certified managers have 2.5 times more critical violations. Lack of supervision leads to: temperature abuse (bacteria double every 20 minutes), cross-contamination spreading pathogens, sick employees working with food, improper cooking allowing pathogen survival. This single violation enables conditions for major outbreaks.
Code Requirements
PIC MUST: Be present during ALL operating hours; Hold valid food safety certification; Actively monitor employee health and hygiene; Ensure proper cooking, cooling, and holding temperatures; Verify foods from approved sources; Monitor handwashing compliance; Ensure equipment properly sanitized; Take immediate corrective actions for violations; Demonstrate knowledge to health inspector; Train and supervise all food employees.
Corrective Actions
IMMEDIATE: Designate qualified PIC immediately; If no certified manager available, cease operations; Implement active managerial control system; Create monitoring logs for all CDC risk factors; Retrain management on responsibilities; Post PIC duties checklist
02-3-602.11-.12/3-302.12
Food Container Labels
Label all bulk food containers to properly identify the contents such as flour and sugar and salt
Why This Matters
Improper labeling can lead to using wrong or expired ingredients
Code Requirements
Immediate correction required. Follow health code section . Implement proper food labeling procedures. Train all staff. Document corrective actions taken.
08-3-305-307.11
Food Protection
Cooking line sandwich unit- ensure all ready to eat foods are not being compromised by raw foods that are stored on top of the sandwich unit segragate and seperate as discussed. No cross contamination observed during inspection
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
10-3-304.12
Food Utensil Storage
Chef knife stored in between soiled equipment Relocate
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper equipment procedures. Train all staff. Document corrective actions taken.
21-3-304.14
Wiping Cloths Clean Sanitize
Discard yellow sponges used to clean food contact surfaces
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
23-4-602.13
Non-Food Contact Surfaces Clean
Clean to remove all visible food spills stains and soils inside and outside all refrigeration units pieces of cooking equipment exterior of all bulk food containers inside microwaves and exterior of all sinks
Why This Matters
INDIRECT CONTAMINATION: Dirty surfaces attract pests, harbor bacteria, and contaminate via contact or air movement. Dust from dirty shelves contains allergens affecting 32 million Americans. Grease accumulation creates slip hazards causing 25% of restaurant injuries.
Code Requirements
Non-food contact surfaces must be cleaned at frequency to prevent: Soil accumulation; Pest attraction; Contamination of food/food contact surfaces. Includes: Equipment exteriors; Shelving; Walls and ceilings; Light fixtures; Ventilation systems.
Corrective Actions
Deep clean all non-food contact surfaces; Create cleaning schedule with daily, weekly, monthly tasks; Assign cleaning zones to staff; Use degreaser for grease accumulation; Clean from top to bottom; Maintain cleaning log
36-6-201.11
Floors Designed Constructed Installed
Repair damaged areas of the kitchen floor near the walk in unit it is starting to pool water
Why This Matters
Poor facility maintenance can harbor pests and prevent proper cleaning
Code Requirements
Smooth, non-porous surfaces; Properly sloped to drains; No gaps or cracks; Maintained clean
36-6-501.11-.12
Improper Maintenance of Floors
Clean floors throughout the facility including underneath all cooking equipment and shelving units from visible food spills stains and soils
Why This Matters
CONTAMINATION RESERVOIR: Damaged floors harbor bacteria in cracks. Standing water breeds Listeria, Pseudomonas. Broken tiles create pest harborage. Floor contamination spreads via shoes, equipment wheels, and dropped items. CDC found floor drains positive for Listeria in 40% of retail delis.
Code Requirements
Floors must be: Smooth and non-porous in food areas; Properly sloped to drains (1/8 to 1/4 inch per foot); Coving at wall junctures sealed; No cracks, holes, or missing tiles; Grout intact and sealed; Cleaned daily or more frequently; Dry except when cleaning.
Corrective Actions
Schedule floor repairs within 30 days; Seal all cracks immediately with approved sealant; Improve drainage to eliminate standing water; Increase cleaning frequency; Replace missing tiles; Re-grout as needed; Remove any carpeting from food areas
37-6-201.11
Walls/Ceilings Designed Constructed Installed
Repair damaged vents in the hood where needed. - expired sticker on hood observed during inspection
Why This Matters
Poor facility maintenance can harbor pests and prevent proper cleaning
Code Requirements
Smooth, washable surfaces; No holes or damage; Light-colored in food areas; Clean condition
37-6-501.11-.12
Improper Maintenance of Walls/Ceilings
Clean walls throughout the facility including behind all cooking equipment and shelving units from visible food spills stains and soils
Why This Matters
OVERHEAD CONTAMINATION: Peeling paint and debris fall into food. Condensation on ceilings drips bacteria onto prep surfaces. Studies found ceiling tiles harbor Bacillus cereus spores. Restaurant ceiling collapse contaminated food service for 200 guests.
Code Requirements
Walls/ceilings must be: Smooth and washable in food areas; Light-colored for easy soil detection; Free of holes, cracks, peeling paint; Sealed at all joints and attachments; Clean and free of grease, dust, cobwebs; Non-absorbent in areas subject to moisture.
Corrective Actions
Repair all holes within 14 days; Repaint with washable paint; Replace damaged ceiling tiles; Seal all penetrations; Clean walls and ceilings monthly; Fix any leaks immediately; Install FRP panels in splash zones
42-6-501.113/.114
Premises Maintained
Remove all personal belongings including clothing bags and electronics from the food service areas and keep segregated as discussed
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.