Jim's Restaurant and Deli
FAILTuesday, March 8, 2022 at 5:27 PM
Violations Cited
590.003/3-304.15-P
(A) Gloves Use Limitation (P)
Observed multiple employees change tasks without changing gloves- Corrected
Why This Matters
FALSE SECURITY: Contaminated gloves spread bacteria MORE than bare hands because workers feel 'protected'. Gloves pick up 5x more bacteria than skin. Not changing between tasks spreads contamination to everything touched.
Code Requirements
Change gloves: After touching raw meat/poultry/fish, Between different food types, After touching face/hair/clothing, Every hour maximum, When switching tasks, After touching any non-food surface. Wash hands BEFORE putting on new gloves.
590.003/3-501.14-P
Cooling (P)
Numerous plastic containers of cooked foods on counters throughout back prep cooling for over an hour with internal temperatures of 100- Reviewed cooling procedures with staff. Products were removed from the plastic containers and put in metal pans over ice to properly finish cooling Review procedures with all staff and reduce the amount of items cooling together to properly monitor cooling temperatures.
Why This Matters
TOXIN FORMATION: Clostridium perfringens spores survive cooking and germinate during slow cooling. Produce toxin that causes violent illness. Responsible for 1 million illnesses annually. Large batches can take 24+ hours to cool unsafely.
Code Requirements
Cool rapidly using: Shallow pans (2 inches max), Ice baths with stirring, Blast chiller, Cut large items into portions, Add ice as ingredient. NEVER cool at room temp. NEVER stack hot containers. Monitor with thermometer. Document cooling times.
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Multiple containers of products held over the cold holding at the front service counter Tuna salad on service line at 53F Ensure products are at and held at 41F or below for service Products removed and placed in refrigeration to cool
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.003/3-501.16-P1
(A)(1) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Diced chicken tenders held on counter at 65F Hot hold products at 135F or above Placed on grill top to reheat
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.004/4-501.114-P
Manual and Mechanical Warewashing Equipment Chemical Sanitization-Temperature pH Concentration and Hardness (P)
At the time of the inspection dishwasher was testing at 0ppm chlorine- Employees were using to warewash Ensure sanitizer level is monitored daily Corrected
Why This Matters
INEFFECTIVE SANITIZATION: Below 50ppm chlorine or 200ppm quat, bacteria survive on 'clean' dishes. Above 200ppm chlorine leaves toxic residue causing chemical burns, nausea. 70% of restaurant outbreaks linked to improper sanitization.
Code Requirements
Maintain sanitizer at: Chlorine 50-100ppm, Quaternary Ammonium 200-400ppm, Iodine 12.5-25ppm. Test every 2 hours with test strips. Change solution when cloudy/dirty. Train all staff on mixing procedures.
590.002(D)/2-103.11-PF
(A)-(P) Person-In-Charge-Duties (Pf)
Multiple priority violations noted on inspection report- Review policies and procedures with staff As of today 03/08/22 the establishmnent does not have a valid 2022 Health Permit. Contact the Health Department to correct immediately
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(D). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-305.11-C
Food Storage-Preventing Contamination from the Premises (C)
Foods observed stored on floors- Sore a minimum of 6" off the floor
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.003/3-501.13-C
Thawing (C)
Numerous products thawing in stagnant water in back prep area- REviewed proper thawing procedures with staff and corrected
Why This Matters
SURFACE CONTAMINATION: Room temperature thawing allows surface to reach 70°F+ while interior frozen. Bacteria multiply 7-fold every hour. Creates perfect conditions for Salmonella, Campylobacter growth. Major factor in poultry-related illnesses.
Code Requirements
Approved thawing methods ONLY: Under refrigeration (best), Under cold running water (70°F) in sink, In microwave if cooking immediately, As part of cooking process. NEVER at room temperature. Plan ahead for slow thawing.
590.004/4-602.13-C
Nonfood Contact Surfaces (C)
Areas including interior and exteriors of refrigeration including handles tracks to refrigeration doors and shelving with soils and debris- Clean
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-501.14-C
Cleaning Ventilation Systems Nuisance and Discharge Prohibition (C)
Hood stickers expired February 2022- SChedue hood cleaning and inspection
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
L1
Condition of issuance for nonpayment of he 2022 Health Permit
Why This Matters
Violations can contribute to foodborne illness if not corrected
Code Requirements
Must comply with all applicable food code requirements