Mala Kungfu
PASSTuesday, July 23, 2019 at 6:33 PM
Violations Cited
590.003/3-501.16-P1
(A)(1) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Observed beef at cooking line above the soup pot registering 115F. PIC discarded it voluntarily. Ensure the TCS food is maintained at 135F or above.
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.004/4-703.11-P
Hot Water and Chemical-Methods (P)
Washing performed at the rinse bay at three bay sink. Unclear where the rinse takes place. Wash rinse sanitize properly in this order at three bay sink.
Why This Matters
CROSS-CONTAMINATION: Skipping steps leaves bacteria and food residue on 'clean' dishes. Studies show improper warewashing spreads bacteria to 73% of dishes. Major cause of Norovirus outbreaks affecting hundreds.
Code Requirements
Follow 5-step process: 1) Scrape/pre-rinse, 2) Wash in 110°F water with detergent, 3) Rinse in clean water, 4) Sanitize for 30 seconds minimum, 5) Air dry (no towel drying). Post procedure at sink. Train all staff.
590.007/7-204.11-P
Sanitizers Criteria-Chemicals (P)
QUATs sanitizer at three bay sink registered over 500ppm. Maintain between 200-400ppm-OK
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.007. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.002(D)/2-103.11-PF
(A)-(P) Person-In-Charge-Duties (Pf)
Retrain staff with regard to proper warewashing and hot holding.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(D). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-302.12-PF
Food Temperature Measuring Devices (Pf)
No food thermomete on site . Provide.
Why This Matters
TEMPERATURE ABUSE: Without thermometers, 73% of foods are held at unsafe temperatures. Bacteria double every 20 minutes between 41-135°F. Undercooked ground beef (not reaching 155°F) causes E. coli outbreaks affecting hundreds.
Code Requirements
Provide calibrated probe thermometers immediately: One per cook station minimum, Range -40°F to 200°F, Accurate to ±2°F, Calibrate daily in ice water (32°F). Check temps every 2 hours for holding, always for cooking.
590.003/3-305.11-C
Food Storage-Preventing Contamination from the Premises (C)
Food stored on the floor inside walk-in unit. Store properly elevated.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.004/4-602.13-C
Nonfood Contact Surfaces (C)
Shelves at the cooking line and storage area soiled. Clean properly.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-903.11-C
(A) and (C) Equipment Utensils Linens and Single-Service and Single-Use Articles-Storing (C)
Observed several single use container boxes stored on the floor at lower level. Store properly elevated.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.006/6-202.13-C
Insect Control Devices Design and Installation (C)
Observed live cockroaches at the lower level. Observed rodent like droppings at the lower level. Provide an IPM report from a licensed exterminator.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper food safety procedures. Train all staff. Document corrective actions taken.