Prieto El Rey De Las Empanadas
FAILWednesday, April 10, 2019 at 5:20 PM
Violations Cited
03-3-501.16
Hot Holding
Beef casava 120F beef croquette 112F cheese casava 109F -maintain hot foods at or above 135F. Owner removed foods to reheat to 165F. Instructed to hold hot in oven if hot holding unit is not able to maintain at or above 135F
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Maintain all hot TCS foods at 135°F or above; Cannot use hot holding equipment to reheat
12-2-301.12-.15
Adequate Handwashing/Where/When/How
Staff unable to wash hands at the handwashing station. No soap and no paper towels. Provide. Instruct staff on proper handwashing.
Why This Matters
Inadequate handwashing is a leading cause of foodborne illness transmission
Code Requirements
Immediate correction required. Follow health code section . Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
20-4-703.11
Food Contact Surfaces Clean
Observed employee wash and rinse metal bowls in middle compartment and place on drying rack without sanitizing. Train staff .
Why This Matters
INVISIBLE KILLERS: Bacteria survive on 'clean-looking' surfaces for days. Inadequate sanitization caused Salmonella outbreak affecting 1,500 people via ice cream. Cutting boards can harbor 200 times more fecal bacteria than toilet seats. E. coli survives 1-4 hours on surfaces. Norovirus survives 2 weeks. One contaminated slicer infected 300 people with Listeria.
Code Requirements
SANITIZATION MANDATORY: Chemical sanitizers: Chlorine 50-100 ppm, Quaternary Ammonium 200-400 ppm, Iodine 12.5-25 ppm; Hot water: 171°F for 30 seconds by immersion; Contact time: minimum 7-30 seconds depending on sanitizer; Test concentration EVERY 2 hours; Change solution when visibly soiled; ALL food contact surfaces must be sanitized: After each use with different foods; When switching raw to ready-to-eat; Every 4 hours in continuous use.
Corrective Actions
IMMEDIATE: Set up proper sanitizer at ALL stations; Test and adjust concentration NOW; Re-sanitize ALL food contact surfaces; Obtain test strips immediately; Post sanitizer concentration chart; Train staff on test strip use; Create sanitization log; Change solutions every 2 hours minimum
M-2-101.11
Person in charge Assigned
No person in charge (PIC) assigned for hot holding warewashing cooling monitoring of staff in their duties. Provide PIC for all operational hours.
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section . Implement proper management & personnel procedures. Train all staff. Document corrective actions taken.
04-3-501.15/4-301.11
Inadequate Facilities/Cooling Methods
Cooked ground beef cooling at room temperature in a deep white plastic food container 102F - 104F. Properly cool cooked foods from 135F - 70 F in 2 hours and 70F - 41F or below in 4 more hours -in shallow pans ice bath or other approved methods. Cover loosely.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
14-4-202.11
Food Contact Surfaces Design
Hot holding unit at 118F. Repair unit. Ensure maintains food at or above 135F. Side of unit is covered in black plastic. Remove and provide a proper repair. Ice stored in cooler without proper drainage. Store to drain melted ice. Chipped bowl and non commercial grade equipment on storage rack. Remove and or replace.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
17-4-302.14
Test Kit Provided
No test kit for quats sanitizer. Provide. Quats 200 PPM
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
23-4-602.13
Non-Food Contact Surfaces Clean
Soiled cloths stored inside fryer cabinet. Remove and maintain clean. Clean soils from door gaskets of dry food storage cabinets.
Why This Matters
INDIRECT CONTAMINATION: Dirty surfaces attract pests, harbor bacteria, and contaminate via contact or air movement. Dust from dirty shelves contains allergens affecting 32 million Americans. Grease accumulation creates slip hazards causing 25% of restaurant injuries.
Code Requirements
Non-food contact surfaces must be cleaned at frequency to prevent: Soil accumulation; Pest attraction; Contamination of food/food contact surfaces. Includes: Equipment exteriors; Shelving; Walls and ceilings; Light fixtures; Ventilation systems.
Corrective Actions
Deep clean all non-food contact surfaces; Create cleaning schedule with daily, weekly, monthly tasks; Assign cleaning zones to staff; Use degreaser for grease accumulation; Clean from top to bottom; Maintain cleaning log
32-6-301.11-02.11
Hand Cleaner Drying Tissue Signage
No paper towels no toilet tissue in dispenser. Provide.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.