Sami's Wrap'N'Roll
FAILTuesday, June 1, 2010 at 2:39 PM
Violations Cited
12-2-301.12-.15
Adequate Handwashing/Where/When/How
Employees are not properly washing their hands. All the handsinks upstairs were blocked at the onset of inspection and there is no handsink in the basement where employees are preparing food.
Why This Matters
Inadequate handwashing is a leading cause of foodborne illness transmission
Code Requirements
Immediate correction required. Follow health code section . Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
20-4-703.11
Food Contact Surfaces Clean
The dishwasher is not reading 180F for the final rinse. Provide proper final rinse temperatures so equipment is properly cleaned and sanitized. (Manager setup 3-compartment sink to wash equipment)
Why This Matters
INVISIBLE KILLERS: Bacteria survive on 'clean-looking' surfaces for days. Inadequate sanitization caused Salmonella outbreak affecting 1,500 people via ice cream. Cutting boards can harbor 200 times more fecal bacteria than toilet seats. E. coli survives 1-4 hours on surfaces. Norovirus survives 2 weeks. One contaminated slicer infected 300 people with Listeria.
Code Requirements
SANITIZATION MANDATORY: Chemical sanitizers: Chlorine 50-100 ppm, Quaternary Ammonium 200-400 ppm, Iodine 12.5-25 ppm; Hot water: 171°F for 30 seconds by immersion; Contact time: minimum 7-30 seconds depending on sanitizer; Test concentration EVERY 2 hours; Change solution when visibly soiled; ALL food contact surfaces must be sanitized: After each use with different foods; When switching raw to ready-to-eat; Every 4 hours in continuous use.
Corrective Actions
IMMEDIATE: Set up proper sanitizer at ALL stations; Test and adjust concentration NOW; Re-sanitize ALL food contact surfaces; Obtain test strips immediately; Post sanitizer concentration chart; Train staff on test strip use; Create sanitization log; Change solutions every 2 hours minimum
31-5-203.11
Number Convenient
The basement has been setup for prep with a table grinders prep sinks and mixers but there is no handsink in the basement. Provide a sink for employees to wash their hands during prep. Discontinue prep in the basement until sink is installed. The three handsinks upstairs were blocked at the onset of inspection. Keep all the handsinks clear so employees can properly wash their hands.
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
14-4-202.11
Food Contact Surfaces Design
They are washing empty milk gallons and reusing them. Provide reusable food grade containers.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
17-4-204.112/.115
Equipment Thermometers
There is no thermometer in the front refrigerator. Provide.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper equipment procedures. Train all staff. Document corrective actions taken.
17-4-302.14
Test Kit Provided
There are ne test strips available. Provide.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
29-5-201/02.11
Installed and Maintained
The handsink in the kitchen has very little pressure. Provide hot and cold water under pressure.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
38-6-202.11
Fixture's not properly shielded
Light fixtures in the basement are not properly shielded. Provide light shields in the basement.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.