Shabu-Zen
FAILWednesday, July 22, 2020 at 3:31 PM
Violations Cited
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Diced celery and sliced carrots observed being left out at room temperature. Discontinue and ensure all TCS foods are being maintained at below 41F.
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.004/4-302.12-PF
Food Temperature Measuring Devices (Pf)
At the time of the inspection there were no food therometers available. Provide.
Why This Matters
TEMPERATURE ABUSE: Without thermometers, 73% of foods are held at unsafe temperatures. Bacteria double every 20 minutes between 41-135°F. Undercooked ground beef (not reaching 155°F) causes E. coli outbreaks affecting hundreds.
Code Requirements
Provide calibrated probe thermometers immediately: One per cook station minimum, Range -40°F to 200°F, Accurate to ±2°F, Calibrate daily in ice water (32°F). Check temps every 2 hours for holding, always for cooking.
590.004/4-302.14-PF
Sanitizing Solutions Testing Devices (Pf)
At the time of the inspection there were no test strips for the 3 bay sink. Provide.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.002(C)/2-102.12-C
(A) Certified Food Protection Manager (C)
At the time of the inspection there was no evidence of a Food Allergen Certification. Provide.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(C). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-304.14-C
Wiping Cloths Use Limitation (C)
In the main kitchen area soiled wiping cloths observed being left out on counter tops. Discontinue and use proper sanitizing solution.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-501.13-C
Thawing (C)
Raw frozen shrimp observed being thawed at room temperature. Discontinue and ensure proper thawing methods are in place.
Why This Matters
SURFACE CONTAMINATION: Room temperature thawing allows surface to reach 70°F+ while interior frozen. Bacteria multiply 7-fold every hour. Creates perfect conditions for Salmonella, Campylobacter growth. Major factor in poultry-related illnesses.
Code Requirements
Approved thawing methods ONLY: Under refrigeration (best), Under cold running water (70°F) in sink, In microwave if cooking immediately, As part of cooking process. NEVER at room temperature. Plan ahead for slow thawing.
590.004/4-101.16-C
Sponges Use Limitation (C)
Sponges observed being used at the 3 compartment sink. Discontinue use.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.005/5-205.15-C
System Maintained in Good Repair (C)
Hand sink on the left hand side of the kitchen is not operating. Address and make any necesary repairs. Additional hand sink in teh main kitchen area is to be used until repairs have been made.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-501.112-C
Removing Dead or Trapped Birds Insects Rodents and other Pest (C)
Sticky fly paper observed hanging directly above clean single use containers. Discontinue and ensure all fly traps are taken down during hours of operation.
Why This Matters
DISEASE VECTORS: Flies carry 100+ pathogens, land on feces then food. Transfer 2 million bacteria per landing. Roaches spread 33 bacteria types, 6 parasitic worms. One roach can contaminate entire kitchen overnight. Major asthma trigger.
Code Requirements
Eliminate immediately: Kill visible pests, Find and eliminate breeding sites, Fix all screens/seal openings, Remove standing water, Clean drains weekly, Professional treatment if over 5 insects seen, Install fly lights/traps.