Taqueria y Pupuseria Cancun
PASSFriday, October 30, 2020 at 3:21 PM
Violations Cited
590.003/3-501.14-P
Cooling (P)
Observed fried pork belly ( 73F)and fried yucca (71F) placed in room temperature for cooling. PIC stated they had been there for 1.5hr and placed them inside refrigerating unit. Ensure that proper cooling is performed under temperature control.
Why This Matters
TOXIN FORMATION: Clostridium perfringens spores survive cooking and germinate during slow cooling. Produce toxin that causes violent illness. Responsible for 1 million illnesses annually. Large batches can take 24+ hours to cool unsafely.
Code Requirements
Cool rapidly using: Shallow pans (2 inches max), Ice baths with stirring, Blast chiller, Cut large items into portions, Add ice as ingredient. NEVER cool at room temp. NEVER stack hot containers. Monitor with thermometer. Document cooling times.
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Observed fried yucca placed in ambient temperature ( 60F) . PIC stated it had been out for 1 hour and placed it inside refrigerating unit. Maintain all TCS food at 41F or below.
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.004/4-501.114-P
Manual and Mechanical Warewashing Equipment Chemical Sanitization-Temperature pH Concentration and Hardness (P)
Observed employee washing dishes in rinse bay and rinsing them in sanitizing bay. PIC states that chlorine is added to detergent. Discontinue. Perform proper warewashing (Wash Rinse Sanitize).
Why This Matters
INEFFECTIVE SANITIZATION: Below 50ppm chlorine or 200ppm quat, bacteria survive on 'clean' dishes. Above 200ppm chlorine leaves toxic residue causing chemical burns, nausea. 70% of restaurant outbreaks linked to improper sanitization.
Code Requirements
Maintain sanitizer at: Chlorine 50-100ppm, Quaternary Ammonium 200-400ppm, Iodine 12.5-25ppm. Test every 2 hours with test strips. Change solution when cloudy/dirty. Train all staff on mixing procedures.
590.002(D)/2-103.11-PF
(A)-(P) Person-In-Charge-Duties (Pf)
Retrain staff with regard to proper cold holding cooling and warewashing.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(D). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-302.12-C
Food Storage Containers Identified with Common Name of Food (C)
Some bulk food containers without labeling. Provide.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.003/3-305.11-C
Food Storage-Preventing Contamination from the Premises (C)
Observed open bag with flour placed at lower level. Ensure that all open bulk food items are stored in enclosed containers.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.