THAI DISH RESTAURANT
FAILThursday, January 20, 2022 at 6:12 PM
Violations Cited
590.003/3-501.14-P
Cooling (P)
Observed broth in ambient temperature for cooling registering 109F. PIC stated they had been out for 20 minutes. Cool properly under temperature control within proper time and temperature limits.
Why This Matters
TOXIN FORMATION: Clostridium perfringens spores survive cooking and germinate during slow cooling. Produce toxin that causes violent illness. Responsible for 1 million illnesses annually. Large batches can take 24+ hours to cool unsafely.
Code Requirements
Cool rapidly using: Shallow pans (2 inches max), Ice baths with stirring, Blast chiller, Cut large items into portions, Add ice as ingredient. NEVER cool at room temp. NEVER stack hot containers. Monitor with thermometer. Document cooling times.
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Large amount Beef 58F Pork Belly 60F placed in room temperature. Mantain at 41F or below.
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.004/4-501.114-P
Manual and Mechanical Warewashing Equipment Chemical Sanitization-Temperature pH Concentration and Hardness (P)
No evidence of proper warewashing taking place. Three Bay Sink not set and missing drain plugs. Utensils/equipment soiled to touch and sight. Perform proper warewashing all the time (wash rinse sanitize).
Why This Matters
INEFFECTIVE SANITIZATION: Below 50ppm chlorine or 200ppm quat, bacteria survive on 'clean' dishes. Above 200ppm chlorine leaves toxic residue causing chemical burns, nausea. 70% of restaurant outbreaks linked to improper sanitization.
Code Requirements
Maintain sanitizer at: Chlorine 50-100ppm, Quaternary Ammonium 200-400ppm, Iodine 12.5-25ppm. Test every 2 hours with test strips. Change solution when cloudy/dirty. Train all staff on mixing procedures.
590.002(D)/2-103.11-PF
(A)-(P) Person-In-Charge-Duties (Pf)
Retrain staff with regard to proper warewashing .
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(D). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.002(C)/2-102.12-C
(A) Certified Food Protection Manager (C)
No Allergen Awarness Certificate posted. Provide.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(C). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-304.14-C
Wiping Cloths Use Limitation (C)
Wiping cloths sanitizer boxes not set up. Observed paper towel rroll at prep area being used to wipe without any sanitizer. Discontinue use wiping cloths in sanitizer solution.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-601.11-C
(B) and (C) Equipment Food-Contact Surfaces Nonfood-Contact Surfaces and Utensils (C)
Several pans soiled to sight and touch with encrusted grease. Clean all properly.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.004/4-602.13-C
Nonfood Contact Surfaces (C)
Exterior and interior of several refrigerating units soiled. Clean all properly.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-904.11-C1
Kitchenware and Tableware-Preventing Contamination (C)
Several pots and pans stored on the floor and against the wall at warewashing area. Elevate properly.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-501.12-C
Cleaning Frequency and Restrictions (C)
Wall and pipes near cooking line with grease build up. Area around grease trap soiled. Floor at warewashing area soiled. Wall at prep area very soiled. Clean all properly.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.006/6-501.14-C
Cleaning Ventilation Systems Nuisance and Discharge Prohibition (C)
Part of hood vent with large amount of grease. Clean to remove.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.