CHINA MAXIM III
PASS W/ CONDITIONSFriday, November 15, 2019 at 7:30 PM
Violations Cited
590.004/4-602.11-P
Equipment Food-Contact Surfaces and Utensils-Frequency (P)
Soils on food containers on cooking line
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.002/2-501.11-PF
Clean-up of Vomiting and Diarrheal Events (Pf)
Every Food Establishment must now have written procedures for responding to and clean-up of vomiting and diarrheal events.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.004/4-302.12-PF
Food Temperature Measuring Devices (Pf)
Provide thin probe thermometer
Why This Matters
TEMPERATURE ABUSE: Without thermometers, 73% of foods are held at unsafe temperatures. Bacteria double every 20 minutes between 41-135°F. Undercooked ground beef (not reaching 155°F) causes E. coli outbreaks affecting hundreds.
Code Requirements
Provide calibrated probe thermometers immediately: One per cook station minimum, Range -40°F to 200°F, Accurate to ±2°F, Calibrate daily in ice water (32°F). Check temps every 2 hours for holding, always for cooking.
590.005/5-202.12-PF
Handwashing Sinks Installation (Pf)
No hand sink in rear prep area
Why This Matters
WITHOUT HOT WATER: Bacteria removal drops by 75%. Studies show proper handwashing with hot water and soap removes 99.9% of bacteria, while cold water only removes 25%. This dramatically increases risk of spreading E. coli, Salmonella, and Norovirus - responsible for 89% of foodborne illness outbreaks.
Code Requirements
Immediate action required: Provide hot water (100-120°F) at ALL handwashing sinks. Install water heater if needed. Temporary solution: heat water for handwashing until repairs complete. Staff must wash hands every 30 minutes, after touching face/hair, handling raw foods, using restroom.
590.002/2-402.11-C
Effectiveness-Hair Restraints (C)
Food handlers not wearing hair restraints
Why This Matters
CONTAMINATION RISK: Average person sheds 50-100 hairs daily. Each hair can carry up to 1 million bacteria. Staphylococcus aureus from hair causes rapid food poisoning (1-6 hours) with severe nausea, vomiting, and cramps. Cannot be killed by reheating once toxin forms.
Code Requirements
All staff handling food MUST wear: hairnets, caps, or effective hair restraints covering all hair; beard nets for facial hair over 1/4 inch; no loose hair touching shoulders. Provide hair restraints for all staff immediately.
590.003/3-302.11-C
Packaged and Unpackaged Food-Separation Packaging and Segregation (C)
Upright refrigeration unit Raw chicken stored above and with food items that are cooked to a lower temperature Walk in refrigeration unit Raw chicken stored above ready to eat foods and food items that are cooked to a lower temperature
Why This Matters
DIRECT CONTAMINATION PATH: Raw chicken contains Salmonella (23% of samples) and Campylobacter (71% of samples). One drop of raw chicken juice can contaminate entire shelf below. Results in 1-3 million US illnesses annually.
Code Requirements
REORGANIZE IMMEDIATELY - Top to bottom: Ready-to-eat foods, Fish/Seafood (145°F), Whole meat/pork (145°F), Ground meat (155°F), Poultry (165°F) on bottom. Use separate coolers if needed. Cover all foods. Train all staff on proper order.
590.003/3-305.11-C
Food Storage-Preventing Contamination from the Premises (C)
Mop sink not enclosed - Rear storage/prep area Using card board boxes to stored foods on serving line - Provide NSF approved food containers
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.004/4-501.11-C
Good Repair and Proper Adjustment-Equipment (C)
Broken door gaskets on interior of refrigeration units Rust on shelving in back ware washing/prep area and in walk in unit Rust on can open stem
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.004/4-502.13-C
Single-Service and Single-Use Articles-Use Limitations (C)
Reusing containers to stored food in that are not NSF approved for reuse
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-602.13-C
Nonfood Contact Surfaces (C)
Built up soils on hand sink knobs etc. - Kitchen/prep/ware washing Built up soils on interior and exterior of refrigeration units
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-901.12-C
Wiping Cloths Air Drying Location (C)
In use wiping cloths not stored in a sanitizing solution - Kitchen/prep/ware washing
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.005/5-501.113-C
Covering Receptacles (C)
Grease bin lid not tight fitting
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-201.11-C
Floors Walls and Ceilings-Cleanability (C)
Built up soils on floor walls and ceiling - Kitchen/prep/ware washing/storage Floor in walk in unit rusted
Why This Matters
Poor facility maintenance can harbor pests and prevent proper cleaning
Code Requirements
Smooth, non-porous surfaces; Properly sloped to drains; No gaps or cracks; Maintained clean