MDM Noodle
PASS W/ CONDITIONSTuesday, June 6, 2023 at 4:42 PM
Violations Cited
590.002/2-301.14-P
When to Wash (P)
Employees noted again in the dining room preparing products- No handwashing sink available in this area Discontinue preparing products at a table in the dining room
Why This Matters
ILLNESS TRANSMISSION: 70% of foodborne outbreaks traced to poor handwashing. Unwashed hands after restroom carry 10 billion bacteria including E. coli. One contaminated hand can spread bacteria to 7 surfaces in 10 seconds. Causes 48 million illnesses annually.
Code Requirements
Wash hands for 20 seconds minimum with soap and 100°F water: After restroom ALWAYS, Before food prep, After touching face/hair/clothing, Between raw and ready-to-eat foods, After handling garbage, Every 30 minutes during continuous prep, After any contamination risk.
590.003(C)/3-301.11-P
Preventing Contamination from Hands (P)
Observed employee peeling cooked eggs in the kitchen with his bare hands- Product discarded Gloves shall be worn while handling products
Why This Matters
Inadequate handwashing is a leading cause of foodborne illness transmission
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003(C). Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
590.003/3-304.15-P
(A) Gloves Use Limitation (P)
Observed an employee behind the establishmnet with gloves on. He returned to the kitchen wearing the same gloves. Corrected on site
Why This Matters
FALSE SECURITY: Contaminated gloves spread bacteria MORE than bare hands because workers feel 'protected'. Gloves pick up 5x more bacteria than skin. Not changing between tasks spreads contamination to everything touched.
Code Requirements
Change gloves: After touching raw meat/poultry/fish, Between different food types, After touching face/hair/clothing, Every hour maximum, When switching tasks, After touching any non-food surface. Wash hands BEFORE putting on new gloves.
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Multiple products stored on a cart at the cookline including mushrooms in water at 81F-Voluntarily Discarded by PIC
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.004/4-501.114-P
Manual and Mechanical Warewashing Equipment Chemical Sanitization-Temperature pH Concentration and Hardness (P)
At the time of the inspection the low temperature dish machine had no sanitizer in the bottle- Maintain proper sanitizer to test at 50-100ppm
Why This Matters
INEFFECTIVE SANITIZATION: Below 50ppm chlorine or 200ppm quat, bacteria survive on 'clean' dishes. Above 200ppm chlorine leaves toxic residue causing chemical burns, nausea. 70% of restaurant outbreaks linked to improper sanitization.
Code Requirements
Maintain sanitizer at: Chlorine 50-100ppm, Quaternary Ammonium 200-400ppm, Iodine 12.5-25ppm. Test every 2 hours with test strips. Change solution when cloudy/dirty. Train all staff on mixing procedures.
590.002(B)/2-102.11-PF
(A) (B) and (C)(1) (4)-(16) Demonstration (Pf)
Multiple priority violations including repeat violations noted on the inspection report- Proper procedures shall be reviewed and followedby all staff
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(B). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003(C)/3-301.11-PF
Preventing Contamination from Hands (Pf)
Observed employee handling raw chicken feet with bare hands during preparation- Corrected
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003(C). Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
590.004/4-303.11-PF
Cleaning Agents and Sanitizers Availability (Pf)
No sanitizer available at the establishment at the time of the inspection- Corrected
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.004/4-601.11-PF
(A) Equipment Food-Contact Surfaces Nonfood-Contact Surfaces and Utensils (Pf)
Multiple pieces of food service equipment with dried on food soils. Includes but not limited to: Mixer stored on floor with dried on soils in the bowl and paddle Peelers stored on a ledge with heavy encrusted soils Slicer and bladewith dried on soils Clean all food service equipment following use and with proper frequency
Why This Matters
Improper equipment maintenance can harbor bacteria and contaminate food
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.003/3-302.12-C
Food Storage Containers Identified with Common Name of Food (C)
Multple squeeze bottles and bulk food containers with no labeling- Provide
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.003/3-304.12-C
In-Use Utensils Between-Use Storage (C)
Multiple knives stored between equipment at the prep line- Removed
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.003/3-304.14-C
Wiping Cloths Use Limitation (C)
Numerous wipping cloths on counters throughout- No sanitizer available at the time of the inspection- Corrected
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-305.12-C
Food Storage Prohibited Areas (C)
Multiple containers with products in them including vegetables and noodles stored on the floor below the 3 bay sink- Removed
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.003/3-305.14-C
Food Preparation (C)
Observed multiple employees preparing dumplings in the dining room on a table- Noted on the last inspection Discontinue preparing products in the dining room on tables
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-602.13-C
Nonfood Contact Surfaces (C)
Multiple areas of the establishment with heavy encrusted soils Areas include but not limited to Walls throughout kitchen Shelving throughout kitchen Exteriors of refrigeration including handles Filters of hood with dripping grease Floors under and behind equipment Clean all areas with proper frequency
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.006/6-501.11-C
Repairing-Premises Structures Attachments and Fixtures-Methods (C)
Multiple areas of the floor in the kitchen with heavily worn grout allowing food and water to accumulate- Repair
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper food safety procedures. Train all staff. Document corrective actions taken.