NOODLE STREET RESTAURANT
FAILThursday, December 8, 2016 at 3:54 PM
Violations Cited
08-3-302.11/3-304.11
Separation Segregation Cross Contamination
At the time of the inspection the raw eggs chicken stored on top of salad unit with food items that are either cooked to a lower temperate or not heat treated. RAW vegetables in contact with Raw chicken.
Why This Matters
Cross-contamination can spread dangerous pathogens throughout the facility
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
12-2-301.12-.15
Adequate Handwashing/Where/When/How
Observed no hand washing during inspection (Manager took corrective action and will continue to train and monitor employee hand washing - gloves being worn continuously - • Gloves are task specific and should NEVER be worn continuously. They get contaminated just as bare hands do so change them out frequently. • Wash your hands properly in between these changes i.e. (a 20 second scrub with soap warm water and don’t forget to dry off with a clean paper towel). • Gloves are not a stand-alone protective barrier. As mentioned above they are not 100% effective but when combined with proper hand washing they significantly reduce the possibility of contaminating your customer’s food. • Gloves can still cross-contaminate. Don’t touch the ready-to-eat food if you have just handled a raw piece of meat or eggs. Throw away the gloves wash your hands and put on a new pair. • If you touch a dirty surface with your glove (hair nose clothing floor equipment or utensils) the glove is dirty and you need to change them after washing your hands. • Bacteria from your skin continue to grow while underneath the gloves and that is why it is important to wash between handling the new gloves. Don’t pre-contaminate your gloves. • Non-latex gloves are recommended in Massachusetts. Keep a box of gloves in a readily accessible area. Perhaps by the hand wash sink. Being careful not to contaminate them here either. • Gloves used for food contact should not be used for money trash cleaning of soiled surfaces
Why This Matters
Inadequate handwashing is a leading cause of foodborne illness transmission
Code Requirements
Immediate correction required. Follow health code section . Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
31-5-204/05.11
Location Accessible
Two covered containers of condiments were observed on the edge of the hand sink. No food storage containers or any other equipment should ever be stored on or within the hand sink basin.
Why This Matters
FORCED NON-COMPLIANCE: Blocked sinks force employees to skip handwashing. Studies show 89% compliance when sinks accessible vs 35% when blocked. Each skipped handwash potentially contaminates multiple food items. Inaccessible sinks contributed to Hepatitis A outbreak affecting 660 people.
Code Requirements
Handwashing sinks must be: Accessible at ALL times; Used ONLY for handwashing; Located within 25 feet of food prep; Clear of all equipment and supplies; Never used for food prep, dishwashing, or chemical disposal; Minimum one sink per 5 workers during peak times.
Corrective Actions
Clear ALL handwashing sinks immediately; Post 'Handwashing Only' signs; Relocate any blocking equipment; Provide alternative sinks for other uses; Train staff on sink designation; Monitor hourly for compliance
41-7-201/04.11
Separation/Sanitizer Criteria
Sanitizing solution 200+ PPM (chlorine) (Manager took corrective action)
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section . Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
41-7-201/04.11
Separation/Sanitizer Criteria
Storing food in Containers used for chemicals Chemicals stored in food prep sink with food being prepped in basin
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section . Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
M-2-102.11
PIC Knowledge
Certified food protection manager's allergen certification expired (the operator shall submit to the health department within 24 hours that a full time on site certified food protection manager has been recertified)
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section . Implement proper management & personnel procedures. Train all staff. Document corrective actions taken.
M-2-103.11
PIC Performing Duties
Duties 2-103.11 Person in Charge. The person in charge shall ensure that: Employees are effectively cleaning their hands by routinely monitoring the employees' handwashing; Employees are preventing cross-contamination of ready-to-eat food with bare hands by properly using suitable utensils such as deli tissue spatulas tongs single-use gloves or dispensing equipment; and Employees are properly trained in food safety as it relates to their assigned duties by the certified food protection manager Allergen poster not posted in employee work area
Why This Matters
EXTREME RISK: Without active management, ALL five CDC risk factors go unchecked. Studies show restaurants without certified managers have 2.5 times more critical violations. Lack of supervision leads to: temperature abuse (bacteria double every 20 minutes), cross-contamination spreading pathogens, sick employees working with food, improper cooking allowing pathogen survival. This single violation enables conditions for major outbreaks.
Code Requirements
PIC MUST: Be present during ALL operating hours; Hold valid food safety certification; Actively monitor employee health and hygiene; Ensure proper cooking, cooling, and holding temperatures; Verify foods from approved sources; Monitor handwashing compliance; Ensure equipment properly sanitized; Take immediate corrective actions for violations; Demonstrate knowledge to health inspector; Train and supervise all food employees.
Corrective Actions
IMMEDIATE: Designate qualified PIC immediately; If no certified manager available, cease operations; Implement active managerial control system; Create monitoring logs for all CDC risk factors; Retrain management on responsibilities; Post PIC duties checklist
M-2-103.11
PIC Performing Duties
The CFPM and PIC must provide proper training of staff and verification that the staff are following regulatory procedure. PIC must over see day to day operations and make corrective action when necessary. Review proper sanitizer set up cloth storage walk-in food storage and hand sink restrictions.
Why This Matters
EXTREME RISK: Without active management, ALL five CDC risk factors go unchecked. Studies show restaurants without certified managers have 2.5 times more critical violations. Lack of supervision leads to: temperature abuse (bacteria double every 20 minutes), cross-contamination spreading pathogens, sick employees working with food, improper cooking allowing pathogen survival. This single violation enables conditions for major outbreaks.
Code Requirements
PIC MUST: Be present during ALL operating hours; Hold valid food safety certification; Actively monitor employee health and hygiene; Ensure proper cooking, cooling, and holding temperatures; Verify foods from approved sources; Monitor handwashing compliance; Ensure equipment properly sanitized; Take immediate corrective actions for violations; Demonstrate knowledge to health inspector; Train and supervise all food employees.
Corrective Actions
IMMEDIATE: Designate qualified PIC immediately; If no certified manager available, cease operations; Implement active managerial control system; Create monitoring logs for all CDC risk factors; Retrain management on responsibilities; Post PIC duties checklist
M-2-201.11/.14 .15
Non-Compliance w/Employee Health Policy
No employee/manager could explain the employee illness policy
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section . Implement proper management & personnel procedures. Train all staff. Document corrective actions taken.
02-3-602.11-.12/3-302.12
Food Container Labels
Food containers not labeled
Why This Matters
Improper labeling can lead to using wrong or expired ingredients
Code Requirements
Immediate correction required. Follow health code section . Implement proper food labeling procedures. Train all staff. Document corrective actions taken.
08-3-305-307.11
Food Protection
Bags and packages of raw meat were observed stored above noodles and beside containers of vegetables. The raw meat must be maintained separate from ready to eat foods and foods of a lower final cooking temperature. Raw meats and eggs could be stored on the shelving on the immediate right / front of the door. Vegetables and prepared foods could be stored on the shelving to the left and rear. An alternative could be to store all meats and eggs on the lower shelving with ready to eat foods and prepared foods on the upper shelving. No food product or packaging storage is permitted on the floor. Correct both.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
14-4-202.11
Food Contact Surfaces Design
Reusing containers that are not NSF approved for reuse for food storage.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
15-4-202.16
Non-Food Contact Surfaces
Mop sink not enclosed
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
15-4-202.16
Non-Food Contact Surfaces
Rust on bottom shelves of prep tables
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
21-3-304.14
Wiping Cloths Clean Sanitize
Wiping cloths were observed on several food preparation and non-food preparation surfaces. Wiping cloths must be stored in sanitizer when not in use. Correct.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
33-5-501.116
Improper Cleaning of Receptacles
The exterior of the trash receptacle stored within the food preparation area was soiled. Clean and maintain clean.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
33-5-501.13-.17
Adequate Number Frequency Vermin Proof
Discontinue using chemical containers for trash receptacles - Discontinue Provide proper trash receptacles with covers
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.