SUISHAYA RESTAURANT
PASS W/ CONDITIONSFriday, December 19, 2014 at 4:05 PM
Violations Cited
12-2-301.12-.15
Adequate Handwashing/Where/When/How
Observed food handler rinsing gloves at hand sink. Proper Glove Use - Food Service Establishments Training Tips: *Single-use disposable gloves have become a popular way to abide by the “No bare hand contact of ready-to-eat (RTE) foods.” regulation. *Single- use gloves are only as clean as the hands that don them. Washing hands thoroughly before and after wearing or changing gloves is one of the most important things food handlers can do. However some food operators may get a false sense of security or worse yet; use gloves as an excuse not to properly wash their hands and overuse the single-use gloves thus defeating their purpose. Gloves are in fact an excellent way to reduce the possibility of contaminating ready-to-eat foods and serve as an extra precautionary measure. According to the Centers for Disease Control and Prevention “The key to gloves efficacy is coupled with proper hygienic practices. Some important tips to remember; • Gloves are task specific and should NEVER be worn continuously. They get contaminated just as bare hands do so change them out frequently. • Wash your hands properly in between these changes i.e. (a 20 second scrub with soap warm water and don’t forget to dry off with a clean paper towel). • Gloves are not a stand-alone protective barrier. As mentioned above they are not 100% effective but when combined with proper hand washing they significantly reduce the possibility of contaminating your customer’s food. • Gloves can still cross-contaminate. Don’t touch the ready-to-eat food if you have just handled a raw piece of meat or eggs. Throw away the gloves wash your hands and put on a new pair. • If you touch a dirty surface with your glove (hair nose clothing floor equipment or utensils) the glove is dirty and you need to change them after washing your hands. • Bacteria from your skin continue to grow while underneath the gloves and that is why it is important to wash between handling the new gloves. Don’t pre-contaminate your gloves. • Non-latex gloves are recommended in Massachusetts. Keep a box of gloves in a readily accessible area. Perhaps by the hand wash sink. Being careful not to contaminate them here either. • Gloves used for food contact should not be used for money trash cleaning of soiled surfaces **Just remember the single-use gloves are meant to protect the food from you not you from the food**
Why This Matters
Inadequate handwashing is a leading cause of foodborne illness transmission
Code Requirements
Immediate correction required. Follow health code section . Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
20-4-703.11
Food Contact Surfaces Clean
Low temp dish washer 0 PPM All ware washing shall be performed in the 3 bay sink. PIC informed all employees. Corrected prior to end of inspection 50 PPM.
Why This Matters
INVISIBLE KILLERS: Bacteria survive on 'clean-looking' surfaces for days. Inadequate sanitization caused Salmonella outbreak affecting 1,500 people via ice cream. Cutting boards can harbor 200 times more fecal bacteria than toilet seats. E. coli survives 1-4 hours on surfaces. Norovirus survives 2 weeks. One contaminated slicer infected 300 people with Listeria.
Code Requirements
SANITIZATION MANDATORY: Chemical sanitizers: Chlorine 50-100 ppm, Quaternary Ammonium 200-400 ppm, Iodine 12.5-25 ppm; Hot water: 171°F for 30 seconds by immersion; Contact time: minimum 7-30 seconds depending on sanitizer; Test concentration EVERY 2 hours; Change solution when visibly soiled; ALL food contact surfaces must be sanitized: After each use with different foods; When switching raw to ready-to-eat; Every 4 hours in continuous use.
Corrective Actions
IMMEDIATE: Set up proper sanitizer at ALL stations; Test and adjust concentration NOW; Re-sanitize ALL food contact surfaces; Obtain test strips immediately; Post sanitizer concentration chart; Train staff on test strip use; Create sanitization log; Change solutions every 2 hours minimum
41-7-102.11
Labeled Common Name
Spray bottle not labeled.
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section . Implement proper food labeling procedures. Train all staff. Document corrective actions taken.
M-2-103.11
PIC Performing Duties
All employees must be trained in food safety and sanitation by the certified food protection manager as it relates to their assigned duties per code. PIC must monitor all employees to ensure establishment operates in a safe and sanitary manner. Multiple risk factors critical non critical violations and repeat violations noted on inspection. Importance of Food Manager Certification: Massachusetts adopted the food manager certification in order to protect public health and prevent foodborne illness. A certificate implies that the person has knowledge of food safety and the prevention of foodborne illness through the control of risk factors. The certified person must be able to apply this knowledge in day-to-day operations in order to provide consumers with safe food. Responsibility of the Certified Food Manager: The certified food protection manager is responsible for monitoring and managing all food establishment operations and to ensure that the facility is operating in compliance with food establishment regulations. The certified PIC must be knowledgeable about foodborne illness prevention and must use this knowledge to recognize hazards and take appropriate preventive and corrective actions.
Why This Matters
EXTREME RISK: Without active management, ALL five CDC risk factors go unchecked. Studies show restaurants without certified managers have 2.5 times more critical violations. Lack of supervision leads to: temperature abuse (bacteria double every 20 minutes), cross-contamination spreading pathogens, sick employees working with food, improper cooking allowing pathogen survival. This single violation enables conditions for major outbreaks.
Code Requirements
PIC MUST: Be present during ALL operating hours; Hold valid food safety certification; Actively monitor employee health and hygiene; Ensure proper cooking, cooling, and holding temperatures; Verify foods from approved sources; Monitor handwashing compliance; Ensure equipment properly sanitized; Take immediate corrective actions for violations; Demonstrate knowledge to health inspector; Train and supervise all food employees.
Corrective Actions
IMMEDIATE: Designate qualified PIC immediately; If no certified manager available, cease operations; Implement active managerial control system; Create monitoring logs for all CDC risk factors; Retrain management on responsibilities; Post PIC duties checklist
22-4-601/602.11
Food Contact Surfaces Clean
Build up on interior of ice bin
Why This Matters
BIOFILM FORMATION: Visible soil indicates biofilms - communities of bacteria protected by slime layers that resist sanitizers. Biofilms on slicers have caused Listeria outbreaks killing 30% of victims. Meat slicer contamination sickened 300 across 6 states. Grease harbors Listeria which grows at refrigeration temperatures.
Code Requirements
Food contact surfaces must be: Visibly clean with no food debris; Free of grease accumulation; Smooth and cleanable; Cleaned and sanitized after each use; Cleaned every 4 hours if in continuous use; Equipment must be disassembled for cleaning when necessary.
Corrective Actions
Clean and sanitize ALL equipment immediately; Disassemble equipment for thorough cleaning; Establish cleaning schedule with assigned responsibilities; Use cleaning checklist; Train on proper disassembly; Increase cleaning frequency
22-4-601/602.11
Food Contact Surfaces Clean
Clean interior of ice machine free of built up soils - Basement Clean interior of in use food storage containers free of built up soils - throughout
Why This Matters
BIOFILM FORMATION: Visible soil indicates biofilms - communities of bacteria protected by slime layers that resist sanitizers. Biofilms on slicers have caused Listeria outbreaks killing 30% of victims. Meat slicer contamination sickened 300 across 6 states. Grease harbors Listeria which grows at refrigeration temperatures.
Code Requirements
Food contact surfaces must be: Visibly clean with no food debris; Free of grease accumulation; Smooth and cleanable; Cleaned and sanitized after each use; Cleaned every 4 hours if in continuous use; Equipment must be disassembled for cleaning when necessary.
Corrective Actions
Clean and sanitize ALL equipment immediately; Disassemble equipment for thorough cleaning; Establish cleaning schedule with assigned responsibilities; Use cleaning checklist; Train on proper disassembly; Increase cleaning frequency
30-5-203.14
Cross Connection Back Siphonage Backflow
No backflow preventer on hose connection (on cooking line)
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
35-6-501.111/.115
Insects Rodents Animals
Evidence of cockroaches Evidence of rodent activity provide full extermination & intergraded pest management report prior to reinspection . *IPM (Intergrated Pest Management) is a combination of all methods of pest control which can aid in preventing reducing and eliminating a potential infestation of pest. It is a detailed inspection report and plan designed specifically for your establishment. IPM Report shall include the following: Reports must identify pests and conditions of the findings in your establishment. The report must identify exact locations of all conditions and course of action to correct deficiencies. If your establishment is without deficiencies reports must indicate such. The following procedures must be provided by your Licensed Pest Control Operator (Exterminator): •Inspection of premises •Identification of pests pest damage and/or potential for pest infestation •Determination of the extent of the pest problem •Appropriate treatment •Action plan for correction including follow up An IPM reporting system will ensure better communication between you and your pest control company.
Why This Matters
DISEASE VECTORS: Mice produce 50-75 droppings daily containing Salmonella, Hantavirus. Cockroaches carry 33 types of bacteria, 6 parasitic worms. Flies regurgitate and defecate on food, spreading E. coli, Shigella. One mouse can contaminate 10 times more food than it eats. Pest allergens trigger asthma in 26% of inner-city children.
Code Requirements
Facility must be pest-free: No live or dead pests; No droppings or urine; No gnaw marks or rub marks; No nesting materials; Effective pest control program; Monthly professional service recommended; All openings sealed; Remove harborage conditions.
Corrective Actions
Call pest control service immediately; Discard ALL contaminated food; Clean and sanitize all affected areas; Seal all openings larger than 1/4 inch; Install door sweeps; Eliminate standing water; Remove clutter; Increase cleaning frequency
02-3-602.11-.12/3-302.12
Food Container Labels
Food containers not labeled.
Why This Matters
Improper labeling can lead to using wrong or expired ingredients
Code Requirements
Immediate correction required. Follow health code section . Implement proper food labeling procedures. Train all staff. Document corrective actions taken.
08-3-305-307.11
Food Protection
All food food storage containers must be raised 6" above the floor on shelving. All open food products must be stored in food grade covered containers.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
08-3-305-307.11
Food Protection
Pipes above ice machine. Provide proper over head protection above ice machine.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
08-3-305-307.11
Food Protection
Provide splashguards on both sides of hands.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
14-4-202.11
Food Contact Surfaces Design
Wooden ladles split & worn. Discontinue use. Worn cutting boards.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
15-4-202.16
Non-Food Contact Surfaces
Provide splash guard between sanitizing bay of 3 bay sink and hand sink.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
15-4-202.16
Non-Food Contact Surfaces
Rust on bottom shelf of small prep table
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
23-4-602.13
Non-Food Contact Surfaces Clean
Clean exterior of low temp dish machine
Why This Matters
INDIRECT CONTAMINATION: Dirty surfaces attract pests, harbor bacteria, and contaminate via contact or air movement. Dust from dirty shelves contains allergens affecting 32 million Americans. Grease accumulation creates slip hazards causing 25% of restaurant injuries.
Code Requirements
Non-food contact surfaces must be cleaned at frequency to prevent: Soil accumulation; Pest attraction; Contamination of food/food contact surfaces. Includes: Equipment exteriors; Shelving; Walls and ceilings; Light fixtures; Ventilation systems.
Corrective Actions
Deep clean all non-food contact surfaces; Create cleaning schedule with daily, weekly, monthly tasks; Assign cleaning zones to staff; Use degreaser for grease accumulation; Clean from top to bottom; Maintain cleaning log
23-4-602.13
Non-Food Contact Surfaces Clean
Clean interior and exterior of all refrigeration units (fan guards door gaskets handles etc.
Why This Matters
INDIRECT CONTAMINATION: Dirty surfaces attract pests, harbor bacteria, and contaminate via contact or air movement. Dust from dirty shelves contains allergens affecting 32 million Americans. Grease accumulation creates slip hazards causing 25% of restaurant injuries.
Code Requirements
Non-food contact surfaces must be cleaned at frequency to prevent: Soil accumulation; Pest attraction; Contamination of food/food contact surfaces. Includes: Equipment exteriors; Shelving; Walls and ceilings; Light fixtures; Ventilation systems.
Corrective Actions
Deep clean all non-food contact surfaces; Create cleaning schedule with daily, weekly, monthly tasks; Assign cleaning zones to staff; Use degreaser for grease accumulation; Clean from top to bottom; Maintain cleaning log
23-4-602.13
Non-Food Contact Surfaces Clean
Clean shelving throughout Clean exterior of all bulk food containers
Why This Matters
INDIRECT CONTAMINATION: Dirty surfaces attract pests, harbor bacteria, and contaminate via contact or air movement. Dust from dirty shelves contains allergens affecting 32 million Americans. Grease accumulation creates slip hazards causing 25% of restaurant injuries.
Code Requirements
Non-food contact surfaces must be cleaned at frequency to prevent: Soil accumulation; Pest attraction; Contamination of food/food contact surfaces. Includes: Equipment exteriors; Shelving; Walls and ceilings; Light fixtures; Ventilation systems.
Corrective Actions
Deep clean all non-food contact surfaces; Create cleaning schedule with daily, weekly, monthly tasks; Assign cleaning zones to staff; Use degreaser for grease accumulation; Clean from top to bottom; Maintain cleaning log
24-4-903.11
Clean Equipment & Utensils Storage
Invert all pots pans etc.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
29-5-201/02.11
Installed and Maintained
Cover on sumpump not sealed
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
32-6-301.11-02.11
Hand Cleaner Drying Tissue Signage
Place paper towels at hand sink
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
36-6-501.11-.12
Improper Maintenance of Floors
Clean floor under & behind all equipment free of built up soils grease and rodent dropping where needed throughout.
Why This Matters
CONTAMINATION RESERVOIR: Damaged floors harbor bacteria in cracks. Standing water breeds Listeria, Pseudomonas. Broken tiles create pest harborage. Floor contamination spreads via shoes, equipment wheels, and dropped items. CDC found floor drains positive for Listeria in 40% of retail delis.
Code Requirements
Floors must be: Smooth and non-porous in food areas; Properly sloped to drains (1/8 to 1/4 inch per foot); Coving at wall junctures sealed; No cracks, holes, or missing tiles; Grout intact and sealed; Cleaned daily or more frequently; Dry except when cleaning.
Corrective Actions
Schedule floor repairs within 30 days; Seal all cracks immediately with approved sealant; Improve drainage to eliminate standing water; Increase cleaning frequency; Replace missing tiles; Re-grout as needed; Remove any carpeting from food areas
36-6-501.11-.12
Improper Maintenance of Floors
Regrowt floor. standing water on floor.
Why This Matters
CONTAMINATION RESERVOIR: Damaged floors harbor bacteria in cracks. Standing water breeds Listeria, Pseudomonas. Broken tiles create pest harborage. Floor contamination spreads via shoes, equipment wheels, and dropped items. CDC found floor drains positive for Listeria in 40% of retail delis.
Code Requirements
Floors must be: Smooth and non-porous in food areas; Properly sloped to drains (1/8 to 1/4 inch per foot); Coving at wall junctures sealed; No cracks, holes, or missing tiles; Grout intact and sealed; Cleaned daily or more frequently; Dry except when cleaning.
Corrective Actions
Schedule floor repairs within 30 days; Seal all cracks immediately with approved sealant; Improve drainage to eliminate standing water; Increase cleaning frequency; Replace missing tiles; Re-grout as needed; Remove any carpeting from food areas
36-6-501.11-.12
Improper Maintenance of Floors
Rust on floor in walk in unit used for dry storage. Floor in basement storage areas not smooth durable and easily cleanable. Maintain all floors throughout per code.
Why This Matters
CONTAMINATION RESERVOIR: Damaged floors harbor bacteria in cracks. Standing water breeds Listeria, Pseudomonas. Broken tiles create pest harborage. Floor contamination spreads via shoes, equipment wheels, and dropped items. CDC found floor drains positive for Listeria in 40% of retail delis.
Code Requirements
Floors must be: Smooth and non-porous in food areas; Properly sloped to drains (1/8 to 1/4 inch per foot); Coving at wall junctures sealed; No cracks, holes, or missing tiles; Grout intact and sealed; Cleaned daily or more frequently; Dry except when cleaning.
Corrective Actions
Schedule floor repairs within 30 days; Seal all cracks immediately with approved sealant; Improve drainage to eliminate standing water; Increase cleaning frequency; Replace missing tiles; Re-grout as needed; Remove any carpeting from food areas
37-6-501.11-.12
Improper Maintenance of Walls/Ceilings
Repair/seal stainless piece on wall at 2 bay sink. Replace broken light switch cover.
Why This Matters
OVERHEAD CONTAMINATION: Peeling paint and debris fall into food. Condensation on ceilings drips bacteria onto prep surfaces. Studies found ceiling tiles harbor Bacillus cereus spores. Restaurant ceiling collapse contaminated food service for 200 guests.
Code Requirements
Walls/ceilings must be: Smooth and washable in food areas; Light-colored for easy soil detection; Free of holes, cracks, peeling paint; Sealed at all joints and attachments; Clean and free of grease, dust, cobwebs; Non-absorbent in areas subject to moisture.
Corrective Actions
Repair all holes within 14 days; Repaint with washable paint; Replace damaged ceiling tiles; Seal all penetrations; Clean walls and ceilings monthly; Fix any leaks immediately; Install FRP panels in splash zones
42-6-501.113/.114
Premises Maintained
Remove all equipment from between under above equipment
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.
42-6-501.113/.114
Premises Maintained
Remove all unnecessary articles from kitchen/ware washing area and properly storage- Cluttered with brooms mops crates used cooking oil storage etc.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section . Implement proper food safety procedures. Train all staff. Document corrective actions taken.