Totto Ramen
FAILMonday, December 13, 2021 at 5:08 PM
Violations Cited
590.002/2-301.14-P
When to Wash (P)
Employees observed loading soiled dishes then not washing hands between clean tasks. Retrain staff.
Why This Matters
ILLNESS TRANSMISSION: 70% of foodborne outbreaks traced to poor handwashing. Unwashed hands after restroom carry 10 billion bacteria including E. coli. One contaminated hand can spread bacteria to 7 surfaces in 10 seconds. Causes 48 million illnesses annually.
Code Requirements
Wash hands for 20 seconds minimum with soap and 100°F water: After restroom ALWAYS, Before food prep, After touching face/hair/clothing, Between raw and ready-to-eat foods, After handling garbage, Every 30 minutes during continuous prep, After any contamination risk.
590.003/3-401.11-P
Raw Animal Foods-Cooking (P)
Eggs stored in soy sauce are under cooked. Discontinue. Foods must be fully cooked if not offered for immediate service with and advisory. Second time violated.
Why This Matters
This violation directly contributes to foodborne illness risk
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-501.14-P
Cooling (P)
Three large plastic containers of broth cooling in three compartment sink. Broth cooling unevenly -125F / 117F/ 111F and only dropping 2-4 degrees in 15 minutes. PIC removing and placing into ice and water bath to rapidly cool.
Why This Matters
TOXIN FORMATION: Clostridium perfringens spores survive cooking and germinate during slow cooling. Produce toxin that causes violent illness. Responsible for 1 million illnesses annually. Large batches can take 24+ hours to cool unsafely.
Code Requirements
Cool rapidly using: Shallow pans (2 inches max), Ice baths with stirring, Blast chiller, Cut large items into portions, Add ice as ingredient. NEVER cool at room temp. NEVER stack hot containers. Monitor with thermometer. Document cooling times.
590.003/3-501.16-P
(A)(2) and (B) Time/Temperature Control for Safety Food Hot and Cold Holding (P)
Fresh noodles stored above the fill line in cold unit 50F. Removed to chill properly to 41F.
Why This Matters
RAPID BACTERIAL GROWTH: At 50°F, E. coli doubles every 30 minutes. At 70°F, it doubles every 20 minutes. After 4 hours above 41°F, bacteria can reach dangerous levels causing severe illness. Common result: 24-72 hours of diarrhea, vomiting, fever, potential hospitalization.
Code Requirements
Immediately discard foods held above 41°F for over 4 hours. Rapidly cool foods above 41°F if less than 2 hours. Check ALL cooler temps every 2 hours with calibrated thermometer. Repair/adjust refrigeration immediately. Never store food in non-refrigerated areas.
590.002(D)/2-103.11-PF
(A)-(P) Person-In-Charge-Duties (Pf)
Person in charge Yuri unable to provide information for reporting illness and symptoms. Final cooking temperatures unknown not monitoring hand washing cooling times / temperatures pest control and not performing duties for preventing food preparation under stairwell. Certified Food Protection Manager must retrain. Corrective actions were taken.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.002(D). Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-501.15-PF
(A )Cooling Methods (Pf)
Using one wand with melted ice and not stirring to cool large containers of broth. PIC changing method to ice and water bath.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.003/3-603.11-PF
Consumption of Animal Foods that are Raw Undercooked or Not Otherwise Processed to Eliminate Pathogens (Pf)
Several items (poached egg tuna etc) without disclosure. Provide.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.004/4-601.11-PF
(A) Equipment Food-Contact Surfaces Nonfood-Contact Surfaces and Utensils (Pf)
Sides of cooking equipment have heavy grease and carbon build up . Floor under and around equipment with soils. Grid panel inside ice machine is soiled. Clean to remove.
Why This Matters
Improper equipment maintenance can harbor bacteria and contaminate food
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.004. Implement proper equipment procedures. Train all staff. Document corrective actions taken.
590.005/5-205.11-PF
Using a Handwashing Sink-Operation and Maintenance (Pf)
Items stored on floor block access to right side hand sink. Maintain clear area and ensure use of hand sink.
Why This Matters
This violation supports conditions that may lead to foodborne illness
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper personal hygiene procedures. Train all staff. Document corrective actions taken.
590.006/6-501.111-PF
Controlling Pests (Pf)
Several fruit flies in and around the onion bin and a few in the dining area. Provide a more detailed licensed exterminator report to ongoing fly issues.
Why This Matters
SEVERE CONTAMINATION: Rodent droppings carry 35+ diseases including Hantavirus (36% mortality rate), Salmonella (20% of cases from rodents), Leptospirosis (kidney/liver failure). Mice contaminate 10 times more food than they eat through urine and droppings.
Code Requirements
IMMEDIATE ACTION: Clean/sanitize all affected areas with 10% bleach solution. Discard ALL exposed food. Seal holes over 1/4 inch (mice) or 1/2 inch (rats). Remove food sources. Install bait stations. Professional extermination within 24 hours.
590.003/3-302.12-C
Food Storage Containers Identified with Common Name of Food (C)
Several food containers without labels. Provide.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.003/3-305.12-C
Food Storage Prohibited Areas (C)
Pork rolls unwrapped and stored under stairwell. Evidence of prep at this area. Remove knife rack and all prep equipment. Discussed no food preparation under starwell with PIC.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.003. Implement proper food storage procedures. Train all staff. Document corrective actions taken.
590.005/5-205.15-C
System Maintained in Good Repair (C)
Restroom hot water at hand sink is not immediate. Ensure proper repair for water at 100F consistently.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper food safety procedures. Train all staff. Document corrective actions taken.
590.005/5-501.116-C
Cleaning Receptacles (C)
Heavy grease build up on grease container and ground below. Clean to remove.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.005. Implement proper cleaning & sanitization procedures. Train all staff. Document corrective actions taken.
590.006/6-501.113-C
Storing Maintenance Tools (C)
Brooms and maintenance equipment not properly stored.
Why This Matters
This violation affects overall sanitation and food safety
Code Requirements
Immediate correction required. Follow health code section 105 CMR 590.006. Implement proper food safety procedures. Train all staff. Document corrective actions taken.